IllustrationHEAD LIGHTS ANGLE LIGHTS WIRES GETTING VERY DRY FROM THE HEAT OF THE LIGHT AND THE INSULATION COMING OFF THE OPTICAL WIRES, LIGHTS GO OUT, POSSIBLE SHORTING AND BECOME VERY UNSAFE.
2006 BMW 5 Series
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all 5 Series years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
1625–50K
2050–75K
1675–100K
11100–150K
2150K+
79 reports with mileage · 6 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports2 fire reports5 injury reports
Exterior Lighting complaints
7 reportsA MESSAGE ON THE VEHICLE DISPLAY SCREEN INDICATED THAT THE RIGHT-SIDE LOW BEAM HEADLIGHT WAS MALFUNCTIONING. I REMOVED THE HEADLIGHT ASSEMBLY TO REPLACE THE BULB AND FOUND THE WIRING INSULATION IS CRUMBLING TO THE TOUCH, RESULTING IN A SHORT CIRCUIT. THE HEADLIGHT BULB IS NOT ACTUALLY BURNED OUT. THERE ARE MANY COMPLAINTS…
Read full complaint
A MESSAGE ON THE VEHICLE DISPLAY SCREEN INDICATED THAT THE RIGHT-SIDE LOW BEAM HEADLIGHT WAS MALFUNCTIONING. I REMOVED THE HEADLIGHT ASSEMBLY TO REPLACE THE BULB AND FOUND THE WIRING INSULATION IS CRUMBLING TO THE TOUCH, RESULTING IN A SHORT CIRCUIT. THE HEADLIGHT BULB IS NOT ACTUALLY BURNED OUT. THERE ARE MANY COMPLAINTS ABOUT THIS ON THE BMW FORUMS BUT BMW AND THE HEADLIGHT MANUFACTURER, HELLA, REFUSES TO ACKNOWLEDGE THE PROBLEM OR DO ANYTHING ABOUT IT. *TR
TL* THE CONTACT OWNS A 2006 BMW 535XI. THE CONTACT STATED THAT THE BRAKE LIGHT ASSEMBLY SHORTED OUT. THE VEHICLE WAS TAKEN TO A DEALER WHO DECIDED TO REPLACE ALL THREE REAR BRAKE LIGHTS, REAR DRIVER SIDE REVERSE LIGHT AND BOTH TURN SIGNALS IN THE REAR. IN ADDITION, THE CONTACT STATED THAT THE DOORS ON THE VEHICLE APPEAR TO CLOSE…
Read full complaint
TL* THE CONTACT OWNS A 2006 BMW 535XI. THE CONTACT STATED THAT THE BRAKE LIGHT ASSEMBLY SHORTED OUT. THE VEHICLE WAS TAKEN TO A DEALER WHO DECIDED TO REPLACE ALL THREE REAR BRAKE LIGHTS, REAR DRIVER SIDE REVERSE LIGHT AND BOTH TURN SIGNALS IN THE REAR. IN ADDITION, THE CONTACT STATED THAT THE DOORS ON THE VEHICLE APPEAR TO CLOSE AND LATCHED AND INADVERTANTLY OPEN. THE CONTACT WAS INFORMED OF RECALL NHTSA CAMPAIGN ID NUMBER: 12V504000 (LATCHES/LOCKS/LINKAGES: DOORS: LATCH) BUT WAS INFORMED IT ONLY AFFECTED THE 2007 MODEL. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 82,000.
THE PANORAMIC SUNROOF ON E60 BMW WAGONS HAS A FAULTY DESIGN OF THE DRAINS WHICH RE-DIRECTS WATER INTO THE REAR OF THE CAR (SPARE TIRE AREA) CAUSING MULTIPLE ELECTRICAL COMPONENTS TO FAIL WHILE DRIVING: LIGHTS, WINDSHIELD WIPERS, DOOR LOCKS, SPEEDOMETER, ETC. IN MY CASE, THE FAILURE OCCURRED TWICE IN A PERIOD OF 18 MONTHS. THE DE…
Read full complaint
THE PANORAMIC SUNROOF ON E60 BMW WAGONS HAS A FAULTY DESIGN OF THE DRAINS WHICH RE-DIRECTS WATER INTO THE REAR OF THE CAR (SPARE TIRE AREA) CAUSING MULTIPLE ELECTRICAL COMPONENTS TO FAIL WHILE DRIVING: LIGHTS, WINDSHIELD WIPERS, DOOR LOCKS, SPEEDOMETER, ETC. IN MY CASE, THE FAILURE OCCURRED TWICE IN A PERIOD OF 18 MONTHS. THE DEALER AND BMW NORTH AMERICA REPAIRED THE CAR AT OWNERS' EXPENSE ALTHOUGH AN EXTENDED WARRANTY WAS IN FORCE. THERE HAS BEEN A TECHNICAL SERVICE BULLETIN ISSUED BY BMW BUT THE DEALER DOES NOT ACKNOWLEDGE THE FLAW AND REFERS TO THE FAILURE BEING CAUSED BY 'ENVIRONMENTAL INFLUENCES'. *TR
THE TAILLIGHTS OF BMWS (MADE IN ABOUT THE LAST THREE YEARS), SOME LEXUS (STARTING ABOUT TWO YEARS AGO) AND SOME CADILLACS (STARTING ABOUT A YEAR AGO) USE LEDS THAT ARE MODULATED ON AND OFF. THESE CAN BECOME A DISTRACTION AT NIGHT WHEN MOVING ONE'S EYES QUICKLY FROM SIDE TO SIDE. IT CAN GIVE THE ILLUSION THAT THERE ARE MORE CA…
Read full complaint
THE TAILLIGHTS OF BMWS (MADE IN ABOUT THE LAST THREE YEARS), SOME LEXUS (STARTING ABOUT TWO YEARS AGO) AND SOME CADILLACS (STARTING ABOUT A YEAR AGO) USE LEDS THAT ARE MODULATED ON AND OFF. THESE CAN BECOME A DISTRACTION AT NIGHT WHEN MOVING ONE'S EYES QUICKLY FROM SIDE TO SIDE. IT CAN GIVE THE ILLUSION THAT THERE ARE MORE CARS ON THE HIGHWAY THAN THERE ARE.
DO YOU HAVE ANY STUDIES INVOLVING THE BRIGHT HEAD LIGHTS AND ACCIDENTS CAUSED BY THESE HEADLIGHT?. *NM
I WAS DRIVING A NEW BMW M5 IN CHICAGO ON LOWER LAKE SHORE DRIVE (THE BRIDGE OVER THE CHICAGO RIVER.) AT APPROXIMATLY 30-35 MILES/HOUR THE CAR WAS NOT CONTROLLABLE AND THIS RESULTED IN TO A MAJOR CRASH WITH SIGNIFICANT INJURY, SEVERAL DEVICES WERE NOT FUNCTIONING PROPERLY INCLUDING THE DEPLOYMENT OF THE AIR-BAGS. I HAVE BEEN DRI…
Read full complaint
I WAS DRIVING A NEW BMW M5 IN CHICAGO ON LOWER LAKE SHORE DRIVE (THE BRIDGE OVER THE CHICAGO RIVER.) AT APPROXIMATLY 30-35 MILES/HOUR THE CAR WAS NOT CONTROLLABLE AND THIS RESULTED IN TO A MAJOR CRASH WITH SIGNIFICANT INJURY, SEVERAL DEVICES WERE NOT FUNCTIONING PROPERLY INCLUDING THE DEPLOYMENT OF THE AIR-BAGS. I HAVE BEEN DRIVING FOR OVER THIRTY YEARS AND DURING THIS TIME I DID NOT EXPERIENCE EVEN A MINOR ACCIDENT NOR DID I EVER RECEIVE A TICKET FOR A TRAFFIC VIOLATION. *JB
Official recalls
722V119000 · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
Mar 2, 2022
BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.
12V126000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Mar 26, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, MODEL YEAR 2004-2010 6-SERIES, MODEL YEAR 2006-2010 M5, AND MODEL YEAR 2007-2010 M6 VEHICLES. THE INSULATED BULKHEAD CONNECTOR FOR THE POSITIVE BATTERY CABLE MAY HAVE BEEN INCORRECTLY ATTACHED TO THE TRUNK FLOOR PANEL, WHICH CAN LEAD TO A LOOSENING OF THE BOLT CONNECTION. AS IT LOOSENS, AN INCREASE IN ELECTRICAL RESISTANCE AT THIS CABLE CONNECTION IS POSSIBLE AND COULD CAUSE THE CABLE CONNECTION TO OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING COULD LEAD TO A FIRE, EVEN WHILE THE VEHICLE IS NOT IN USE. AS A PRECAUTION, OWNERS ARE ADVISED TO PARK OUTSIDE UNTIL THE REMEDY HAS BEEN MADE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND SECURE THE BATTERY BOLT CABLE CONNECTION AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
10V446000 · Service Brakes, Hydraulic:power Assist:vacuum
Oct 1, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.
Consequence & remedy
Consequence: POWER ASSIST BRAKING PERFORMANCE COULD BE ADVERSELY AFFECTED. IN EXTREME CASES THERE COULD BE A COMPLETE LOSS OF POWER ASSIST BRAKING. AN UNEXPECTED REDUCTION OR LOSS IN POWER BRAKING ASSIST MAY INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
08V384000 · Air Bags:frontal
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
06V277000 · Suspension:rear:shock Absorber
Jul 26, 2006
ON CERTAIN PASSENGER VEHICLES, THE LOWER RUBBER MOUNT OF THE REAR SHOCK ABSORBERS MAY NOT HAVE BEEN MANUFACTURED TO SPECIFICATIONS AND MAY NOT ADHERE CORRECTLY TO ITS HOUSING WITHIN THE SHOCK ABSORBER.
Consequence & remedy
Consequence: THE BUSHING COULD LOOSEN AND OVER TIME COULD SEPARATE FROM ITS HOUSING. THE DRIVER WILL EXPERIENCE IMPAIRED VEHICLE HANDLING AND CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR SHOCK ABSORBER FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 13, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
06V187000 · Suspension:front:control Arm
May 30, 2006
ON CERTAIN PASSENGER VEHICLES, THE NUTS WHICH SECURE THE FRONT AXLE CONTROL ARM AND TENSION STRUT TO THE FRONT WHEEL HUB MAY NOT HAVE BEEN TIGHTENED TO SPECIFICATION. OVER TIME THE NUTS COULD LOOSEN AND THE CONTROL ARM AND TENSION STRUT COULD BE DAMAGED.
Consequence & remedy
Consequence: VEHICLE HANDLING AND CONTROL COULD COMPROMISE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RETIGHTEN THE FRONT AXLE CONTROL ARM AND TENSION STRUT NUTS TO THE CORRECT SPECIFICATIONS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 28, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
05V504000 · Power Train:automatic Transmission
Nov 1, 2005
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.
Consequence & remedy
Consequence: THIS COULD CAUSE THE PARKING LOCK SYSTEM NOT TO ENGAGE, AFTER THE TRANSMISSION IS PLACED IN THE PARK ("P") POSITION. IF THE VEHICLE WAS PARKED ON AN INCLINE, AND THE PARKING BRAKE WAS NOT ENGAGED, THIS COULD RESULT IN A VEHICLE ROLLAWAY CONDITION.
Remedy: DEALERS WILL REPAIR AND REPLACE THE AUTOMATIC TRANSMISSION GUIDE PLATE FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT BMW AT 1-800-332-4269.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).