2008 BMW 335I

As of recently I've been smelling a gas smell after driving my vehicle. No matter the distance or time I smelled the odor of gas. I am a certified automotive technician, so I decided to diagnose the problem myself. I put my vehicle in the air and spotted a wet spot of gas on the bottom left side of my fuel tank. To continue my diagnosis process I googled to see if anyone dealt with a similar issue. Seen a decent amount of people confirming the problem. A leak from the D/S fuel sending unit. So I take off my rear seats, and takeoff the fuel sending unit cover. Once the cover was off seen multiple cracks along side top of the unit. No warning lights was present, however did notice MPG was getting worse and worse. the little cracks makes my vehicle a fire hazard. I was able to have the replacement part ordered for about $140.

The engine and all electrical components including power steering spontaneously cutout while driving, usually while engine isnt being stressed at all, sometimes while idling. If the car is rolling, i have to restart the engine while driving and using manual power to steer. Obviously, this is a huge safety problem. I've just had the alternator and battery replaced, and they test fine. This has happened at least 50 times and I've reduced time driving vehicle until I solve the issue, which has persisted at least 6 months. I asked the BMW dealer about the following recall, and they claim they already performed it years ago after I already owned the car, without my recalling being told it was done. However, the symptoms are back, and BMW refuses to do anything about it at this time: Report Receipt Date: FEB 07, 2013 NHTSA Campaign Number: 13V044000 Component(s): ELECTRICAL SYSTEM Potential Number of Units Affected: 504,545 All Products Associated with this Recall Details 2 Associated Documents Manufacturer: BMW of North America, LLC SUMMARY: BMW is recalling 2007-2011 3-Series sedans manufactured March 2007 through October 2011. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle. CONSEQUENCE: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash. REMEDY: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall is expected to begin in March 2013.

I am experiencing a know issue others have complained about related to the high pressure fuel injector failure in my vehicle. There have been previous recalls for this and my vehicle should fall within the recall dates and is showing all of the symptoms of this failure yet is it some how not part of the recall. What is happening is on cold starts or even idle the car is shaking and has a very apparent misfire, I have checked the spark plugs and they indeed have fuel on them. The injectors are causing excessive fuel in the cylinder this leads to a host of problems that are potentially, catastrophic like the engine seizing while driving due to oil dilution from the fuel

I WAS TOLD BY MY MECHANIC MY FUEL INJECTORS HAVE GONE BAD AND I BELIEVE THIS IS FROM A MANUFACTURER'S ISSUE. PLEASE INVESTIGATE AS I KNOW VARIOUS PEOPLE THAT HAVE THE SAME ISSUE WITH THE SAME ENGINE, YEAR AND MAKE. I TOOK IT TO THE SHOP AFTER I TURNED IT ON TO DRIVE AND THE VEHICLE WAS SHAKING A BIT MORE THAN NORMAL, WHEN I ACCELERATED THE CAR WAS VERY VAGUELY RESPONDING TO ME. THIS IS WHY MY VEHICLE BEGAN TO MISFIRE, BECAUSE OF THE FUEL INJECTORS. I WILL KEEP ALL RECEIPTS UNTIL FURTHER NOTICE OF THIS ISSUE.

01MAY2020. BROUGHT 2008 BMW 335I TO SOUTH ATLANTA BMW DEALERSHIP TO REPLACE REAR BRAKE PADS (BASED ON INSPECTION REPORT FROM A JAN2020 APPT). IT WAS DETERMINED THAT: 1. OIL FILTER HOUSING GASKET: FILTER HOUSING GASKETS & OIL COOLER O-RINGS LEAKING OIL 2. RADIATOR HOSE REPLACEMENT. UPPER COOLANT HOSE TURNING BROWN AND SEEPING. 01MAY2020. RADIATOR HOSE WAS REPLACED ALONG WITH CONDUCTING BRAKE FLUID FLUSH AND MICRO FILTER. SAME DAY AFTER REPAIRS WERE COMPLETE THE CAR STALLS AND SHUTS OFF AND BECOMES UNABLE TO DRIVE. CAR IS TOWED BACK TO DEALERSHIP FOR FURTHER INSPECTION. UPON FURTHER INSPECTION THE FOLLOWING ARE IDENTIFIED: 1. FUEL PUMP REPLACEMENT: R&R HIGH PRESSURE FUEL PUMP & LOW PRESSURE SENSOR PER FAULT CODE 29F2 2.TURBOCHARGER - VARIABLE BOOST CONTROL SOLENOID: BOTH VANOS SOLENOIDS & OIL CHANGE PER SIB. DEALERSHIP INFORMS ME THAT THE FUEL PUMP'S WARRANTY HAS BEEN EXTENDED 10 YEARS/120000 MILES DUE TO MANUFACTURING ISSUES WITH THE FUEL PUMP. I HAVE NEVER BEEN MADE AWARE OF ISSUES WITH THE FUEL PUMP OR EXTENDED WARRANTIES FOR REPLACING. I DO THINK I SHOULD BE RESPONSIBLE FOR REPAIRS ON A MALFUNCTIONING FUEL PUMP THAT WAS POORLY MANUFACTURED. BMW SHOULD BE RESPONSIBLE FOR THE REPLACEMENT AND REPAIR. *TR

THE HIGH PRESSURE FUEL PUMP WHICH WAS RECALLED AND REPLACED IN 2011 IS PROBLEMATIC AGAIN. WHEN PUSHING THE GAS PEDAL HARDER, THE CAR STUTTERS AND DOES NOT RESPOND TO THE EXTRA POWER REQUESTED BY FLOORING THE GAS PEDAL AND MAKES PUT ME IN A DANGEROUS SITUATION. THE 'SERVICE ENGINE SOON' LIGHT CAME UP AS WELL. I PULLED THE CAR OVER WHEN I COULD, STOPPED AND STARTED THE ENGINE AGAIN AND THE "SERVICE ENGINE" LIGHT DISAPPEARED. THIS IS THE SAME ISSUE BACK IN 2011 AND RECURRING AGAIN. I SUSPECT THIS HAS BEEN THERE FOR A LONG TIME, BUT AS MY WIFE DOES NOT PUNCH THE GAS AS HARD AS ME, SHE NOTICED THIS ONLY ON FEW OCCASIONS. I NOTICED THIS TWICE IN THE LAST MONTH AND SO, CALLED THE STEALERSHIP AND LOGGING A COMPLAINT HERE. IN 2011, THEY SAID BMW EXTENDED THE WARRANTY TO 10 YEARS AND SO, THIS SHOULD BE COVERED NOW AS WELL, BUT THE STEALERSHIP ABVIOUSLY WOULD NOT ACKNOWLEDGE. HOPE OUR GREAT PRESIDENT TRUMP SHOW GERMANY THEIR PLACE, AND HOPE BMW PAYS FOR THE TERRIBLE ENGINEERING TILL ELON MUSK MAKES THEM GO BANKRUPT.

HIGH PRESSURE FUEL PUMP FAILURE COULD BE THE LOW PRESSURE FUEL PUMP NOT SO SURE GOT CODES P3090 CONFIRMED AND P142E PENDING. THE CAR WAS IN MOTION WHEN DOING A TURN THE VEHICLE STARTED TO BOG OUT AND ROUGHLY IDLE I IMMEDIATELY TURNED TO THE RIGHT AND SHUT THE VEHICLE OFF TRIED TO START IT ABOUT THREE TIMES IN ONE MINUTE INTERVALS CAR WOULD BOG OUT AND SHUT OFF THREW ME THOSE TWO CODES AND A CHECK ENGINE LIGHT.

I WAS DRIVING AND ALL OF A SUDDEN I COULD NOT STEER, AND THE POWER WAS GONE; IT WAS BARELY MOVING; AND THE LIGHT CAME ON SAYING TO CONTINUE TO DRIVE WITH DIMINISHED SPEED. I WAS CLOSE TO HOME ON AN ACCESS ROAD; AND WAS ABLE TO LIMP HOME. IT WAS ALMOST IMPOSSIBLE TO TURN THE STEERING WHEEL. I TOOK IT TO GLOBAL BMW IN METRO ATLANTA; AND PAID CLOSE TO $3000 FOR REPAIRS. APPROXIMATELY A MONTH LATER I HAD A PROBLEM AGAIN. THE LIGHT CAME ON AND STATED ENGINE MALFUNCTION; REDUCED POWER, PROCEED WITH CAUTION. IN DOING RESEARCH THIS MORNING; I DISCOVERED THAT THERE WAS A RECALL ON MY VEHICLE FOR THIS EXACT PROBLEM. I DID NOT KNOW IT; BUT GLOBAL BMW HAD TO KNOW IT. I CALLED BMW RECALL AND THEY CLAIM THAT THEY ARE WAITING ON THE PARTS. THIS RECALL HAS BEEN IN EFFECT SINCE 2010; SO THEY MUST HAVE THE PARTS. MOST OF THE LAWSUITS WERE SETTLED OUT OF COURT WITH A GAG ORDER; SO IT APPEARS THAT BMW DON'T RESPOND UNLESS THERE IS A FORMAL COMPLAINT; AND THIS IS THE REASON FOR THIS COMPLAINT WITH YOUR OFFICE. I WILL APPRECIATE ANY ASSISTANCE THAT YOU MAY PROVIDE.

MY CAR BEGAN TO RUN ROUGHLY AFTER A COLD START AS I WAS LEAVING MY OFFICE. AFTER A FEW SECONDS AND FEELING DECREASED POWER, I TRIED TO PULL OFF THE ROAD AND INTO A PARKING SPOT IN THE PARKING GARAGE AT MICROSOFT'S HEAD QUARTERS (WHERE I WORK). THE VEHICLE STALLED OUT. I WAS ABLE TO RESTART THE VEHICLE AND GET INTO A PARKING SPACE, BUT IT CONTINUE TO RUN ROUGHLY. I NOTICED AN INTENSE SMELL OF GASOLINE AND IMMEDIATELY TURNED OFF THE ENGINE. I EXITED THE VEHICLE AND CHECKED THE EXHAUST. IT WAS BLOWING WHITE SMOKE AND HAD GASOLINE DRIPPING OUT OF THE TAIL PIPES, I LET THE VEHICLE COOL DOWN AND RESTARTED THE ENGINE WITH ANOTHER PERSON OBSERVING THE TAIL PIPE. IT AGAIN WAS RUNNING VERY ROUGH AND HAD GASOLINE SPRAYING OUT OF THE TAIL PIPE. I IMMEDIATELY TURNED OFF THE ENGINE. THE CAR WAS TOWED TO A SERVICE CENTER. THEY HAVE DIAGNOSED THE ISSUE IS THAT 2 OF THE INJECTORS ARE STUCK IN THE FULLY OPEN POSITION. AS A RESULT, THE CAR IS UNSAFE (I WAS LUCKY THERE WASN'T A MASSIVE FIRE). PREVIOUSLY, I'D HAD THE HPFP (HIGH PRESSURE FUEL PUMP) REPLACED UNDER RECALL. I AM CONCERNED THAT THE RECALLED/REPLACED HPFP MAY ITSELF BE DEFECTIVE AND FAILED, CAUSING 2 INJECTORS TO FAIL SIMULTANEOUSLY (THERE'S STATISTICALLY NO CHANCE OF TWO INJECTORS FAILING SIMULTANEOUSLY WITHOUT SOME CAUSAL FACTOR UPSTREAM IN THE FUEL SYSTEM). ON CONTACTING BMW (IN BELLEVUE WA) AND BMW NORTH AMERICA, THEY HAVE REFUSED TO COVER THE REPAIR OR ACKNOWLEDGE THE ISSUE. I AM CONTINUING TO ENGAGE WITH THEM ON THE REPAIR, BUT BELIEVE THIS IS A MORE SERIOUS SAFETY ISSUE. HAD I NOT PULLED OFF WHEN I DID, THE VEHICLE COULD HAVE WENT UP IN FLAMES WHILE ON THE HIGHWAY.

I'VE HAVE HAD SEVERAL ISSUES INVOLVING THE FUEL PUMP/INJECTORS. ALL SERVICE HAS BEEN PERFORMED AT THE SAME DEALER. THE COST HAS EXCEEDED 3500.00 IN THE LAST 3 YEARS. CAR IS IN THE SHOP AGAIN, DEALER INDICATES FUEL INJECTORS ARE THE PROBLEM, ANOTHER 1989.00 TO GET THE CAR FIX. I BELIEVE THIS IS TOO MUCH $ FOR THE SAME ISSUE FOR A 3 YEAR PERIOD. *TR