Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 18 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
What owners actually said
18 reports
Mileage unknown · Feb 23, 2016
Air Bags
TL* THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTAC…
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10837821
Mileage unknown · Jul 29, 2015
Air Bags
2003 BMW 330CI. CONSUMER WRITES IN REGARDS TO AIRBAG RECALL INSTALLATION PROBLEMS. *SMD THE CONSUMER STATED AFTER HAVING THE AIR BAG PART INSTALLED, THE LIGHT REMAINED ON WITH NO EXPLANATION FROM THE DEALER. THE CONSUMER WENT TO ANOTHER DEALER, WHERE THEY FOUND A MODULE NEEDED TO BE REPLACED TO CORRECT THE PROBLEM. *JB
NHTSA ODI #10744285
110,000 miles · May 20, 2014
Electrical System
GM5 ELECTRIC MODULE STOPPED COMMUNICATING WITH REMOTE CONTROL. VARIOUS INTERMITTENT ACTIVITY FOR DRIVER DOOR UNLOCK MECHANISM AND PASSENGER UNLOCK MECHANISM BY ANY AVAILABLE INTERNAL HARD-WIRED OR REMOTE BUTTON. 100% FAILURE OF FOOTWELL TRUNK RELEASE BUTTON. *TR
NHTSA ODI #10592627
120,000 miles · Apr 1, 2013
Electrical System
DROVE FOR ABOUT 2 HOURS. LEFT THE CAR PARKED FOR ABOUT 3 HOURS. WHEN I TRIED TO UNLOCK PASSENGER DOOR VIA REMOTE KEY FOB IT DID NOT. I GOT INSIDE THE CAR AND TRIED TO UNLOCK IT MANUALLY BUT IT STILL DID NOT LET ME. I HAD MY HANDICAPPED SISTER WITH ME AND IT WAS IMPOSSIBLE TO GET HER INSIDE THE CAR. I HAD SOMEBODY COME TO PICK HE…
Read full complaint
DROVE FOR ABOUT 2 HOURS. LEFT THE CAR PARKED FOR ABOUT 3 HOURS. WHEN I TRIED TO UNLOCK PASSENGER DOOR VIA REMOTE KEY FOB IT DID NOT. I GOT INSIDE THE CAR AND TRIED TO UNLOCK IT MANUALLY BUT IT STILL DID NOT LET ME. I HAD MY HANDICAPPED SISTER WITH ME AND IT WAS IMPOSSIBLE TO GET HER INSIDE THE CAR. I HAD SOMEBODY COME TO PICK HER UP AFTER OVER 3 HOURS. I HAVE NEVER SEEN ANOTHER CAR THAT WILL NOT UNLOCK AT LEAST MANUALLY WHEN YOU PULL THE DOOR LEVER ON THE INSIDE OR LIFT THE LOCK MECHANISM MANUALLY. NEXT DAY THE LOCK WORKED IN THE MORNING BUT AS THE DAY GOT HOTTER IT STOPPED WORKING AGAIN AND IT WOULD NOT UNLOCK EVEN MANUALLY. *TR
NHTSA ODI #10505303
100,000 miles · Oct 11, 2012
Exterior Lighting
TL* THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT STATED THAT THE TURNING SIGNALS AND BRAKE LIGHTS FAILED. THE CONTACT REPLACED THE BULB LIGHT; HOWEVER THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE MANUFACTURER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPA…
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT STATED THAT THE TURNING SIGNALS AND BRAKE LIGHTS FAILED. THE CONTACT REPLACED THE BULB LIGHT; HOWEVER THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE MANUFACTURER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING: TURN SIGNAL) THE APPROXIMATE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 104,000.
NHTSA ODI #10479727
101,000 miles · Jan 21, 2011
Power Train
TL*THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT STATED THAT WHEN TRYING TO PUT HER VEHICLE IN REVERSE IT WOULD NOT MOVE. WHILE SHIFTING INTO DRIVE IT MADE A LOUD NOISE BEFORE PROCEEDING FORWARD. THE VEHICLE WAS INSPECTED BY A DEALER WHO STATED THAT SHE NEEDED TO REPLACE THE TRANSMISSION. THE VEHICLE HAD NOT BEEN REPAIRED. THE …
Read full complaint
TL*THE CONTACT OWNS A 2003 BMW 330CI. THE CONTACT STATED THAT WHEN TRYING TO PUT HER VEHICLE IN REVERSE IT WOULD NOT MOVE. WHILE SHIFTING INTO DRIVE IT MADE A LOUD NOISE BEFORE PROCEEDING FORWARD. THE VEHICLE WAS INSPECTED BY A DEALER WHO STATED THAT SHE NEEDED TO REPLACE THE TRANSMISSION. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 101,000.
NHTSA ODI #10378147
20,000 miles · Sep 1, 2006
Structure
DT*: THE CONTACT STATED THERE WAS A TEMPERATURE SENSOR UNDER THE RIGHT SIDE OF THE FRONT BUMPER. WHEN PULLING INTO PARKING SPACES WITH A CONCRETE PARKING BLOCK, THE SENSOR WOULD COME IN CONTACT WITH THE CONCRETE BLOCK. THE CONTACT ALSO INDICATED THAT THE BUMPER WAS TOO LOW TO THE GROUND PUTTING THE TEMPERATURE SENSOR AT RISK O…
Read full complaint
DT*: THE CONTACT STATED THERE WAS A TEMPERATURE SENSOR UNDER THE RIGHT SIDE OF THE FRONT BUMPER. WHEN PULLING INTO PARKING SPACES WITH A CONCRETE PARKING BLOCK, THE SENSOR WOULD COME IN CONTACT WITH THE CONCRETE BLOCK. THE CONTACT ALSO INDICATED THAT THE BUMPER WAS TOO LOW TO THE GROUND PUTTING THE TEMPERATURE SENSOR AT RISK OF DAMAGE. UPDATED 10/4/2006 - *NM
NHTSA ODI #10167243
Mileage unknown · Jul 19, 2004
Tires
PROBLEMS WITH MICHELIN TIRES ON 2003 BMW 330 CI.*MR THE CONSUMER HAD A DAMAGED MICHELIN TIRE REPLACED BUT ONLY FOUR MONTHS LATER THE NEW TIRE IS EXHIBITING THE SAME SYMPTOMS AS THE OLD TIRE. THE CONSUMER BELIEVES THE TIRES BECAME TOO HOT THEREFORE CREATING 3-4 INCH BUBBLES AROUND THE WALL WHICH CAUSED THE TIRE TO LOSE AIR. …
Read full complaint
PROBLEMS WITH MICHELIN TIRES ON 2003 BMW 330 CI.*MR THE CONSUMER HAD A DAMAGED MICHELIN TIRE REPLACED BUT ONLY FOUR MONTHS LATER THE NEW TIRE IS EXHIBITING THE SAME SYMPTOMS AS THE OLD TIRE. THE CONSUMER BELIEVES THE TIRES BECAME TOO HOT THEREFORE CREATING 3-4 INCH BUBBLES AROUND THE WALL WHICH CAUSED THE TIRE TO LOSE AIR. *NM
BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PSPI passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the passenger's front air bag, free of charge. The recall began February 13, 2020. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons, and 2003 X5 3.0i and 4.4i Sports Activity Vehicles. Please note that the 5-series and X5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall began Aug 2016. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall supersedes recall 14V-348 in its entirety. Additionally, vehicles that have had their driver side frontal air bag replaced previously as part of a recall remedy need to have their air bag replaced under this recall as well. Note: On December 17, 2015 BMW removed the model year 2004 X5 3.0i and 4.4i Sports Activity vehicle from this recall. Those vehicles were mistakenly identified as including the air bags that are subject to this recall.
BMW is recalling certain model year 2002-2003 325i, 325xi, 330i, 330xi sedans; 325Ci and 330Ci coupes and convertibles; 325iT and 325xiT Sports Wagons; and M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW intends to issue initial notifications to owners informing them of the safety defect in June 2013. Once replacement parts are available, estimated for July, BMW will notify owners again to contact their dealers and schedule a replacement of the passenger air bag, free of charge. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 BMW 330CI Problems, Complaints & Recalls | Skip That Year
Illustration