NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
20 reportsClear category filter100,000 miles · Aug 4, 2017
Fuel/propulsion System
TAKATA RECALL: THE CAR WHILE BEING DRIVEN WILL JUST STALL ALL POWER IS LOST, AND THEN AFTER ABOUT 30 MINUTES IT WILL START BACK UP. IT IS HARD TO HAVE IT REPAIRED BECAUSE IT IS NOT DISPLAYING THE ISSUE WHEN THE MECHANIC LOOKS AT IT. BUT IS SHOWS AN ERRORS CODE OF FUEL PUMP OVER HEATING. I HAVE HAD ALL SEVERAL REPAIRS DONE AND NO…
Read full complaint
TAKATA RECALL: THE CAR WHILE BEING DRIVEN WILL JUST STALL ALL POWER IS LOST, AND THEN AFTER ABOUT 30 MINUTES IT WILL START BACK UP. IT IS HARD TO HAVE IT REPAIRED BECAUSE IT IS NOT DISPLAYING THE ISSUE WHEN THE MECHANIC LOOKS AT IT. BUT IS SHOWS AN ERRORS CODE OF FUEL PUMP OVER HEATING. I HAVE HAD ALL SEVERAL REPAIRS DONE AND NOTHING HELPS. I CAN'T JUST KEEP DUMPING MONEY IN TO SEE IF THIS MIGHT ELIMINATE THE ISSUE. I SEE THIS HAS BEEN A PROBLEM WITH A NUMBER OF BMW MODELS. I CAN NOT SAFELY DRIVE THE CAR OR SELL IT, IT COULD CAUSE A HORRIFIC AUTO ACCIDENT. I BELIEVE IT IS AN ISSUE INVOLVING SOME PART OF THE FUEL PUMP SYSTEM. I HAVE SEEN RECALLS FOR SOME BMW MODELS WITH THESE ISSUE BUT NOT MINE. I HAVE HAD IT IN THE SHOP 5 TIMES SINCE APRIL
NHTSA ODI #11012897
150,000 miles · May 11, 2017
Fuel/propulsion System
TL* THE CONTACT OWNS A 2009 BMW 328I. WHILE DRIVING APPROXIMATELY 75 MPH, THE FUEL PUMP INDICATOR ILLUMINATED AND THE VEHICLE STALLED AND SHUT OFF. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. THE CONTACT WAITED FOR A WHILE IN THE PRESENCE OF A POLICE OFFICER, WHO WAS ABOUT TO CALL FOR A TOW TRUCK WHEN THE VEHICLE RESTARTED.…
Read full complaint
TL* THE CONTACT OWNS A 2009 BMW 328I. WHILE DRIVING APPROXIMATELY 75 MPH, THE FUEL PUMP INDICATOR ILLUMINATED AND THE VEHICLE STALLED AND SHUT OFF. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. THE CONTACT WAITED FOR A WHILE IN THE PRESENCE OF A POLICE OFFICER, WHO WAS ABOUT TO CALL FOR A TOW TRUCK WHEN THE VEHICLE RESTARTED. THE CONTACT STARTED TO DRIVE AWAY, BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
NHTSA ODI #10984943
108,000 miles · May 3, 2017
Fuel/propulsion SystemSteeringVehicle Speed Control
WHILE DRIVING THE CAR, IT LOSES POWER COMPLETELY AND THE ENGINE SHUTS OFF. THIS HAS HAPPENED SEVERAL TIMES WHILE DRIVING ON THE FREEWAY AT HIGH SPEED. IT IS A VERY DANGEROUS SITUATION, AS THE CAR QUICKLY DECELERATES AND POWER STEERING NO LONGER WORKS. I HAVE BEEN INCREDIBLY LUCKY TO BE ABLE TO GET TO THE SIDE OF THE HIGHWAY AFTE…
Read full complaint
WHILE DRIVING THE CAR, IT LOSES POWER COMPLETELY AND THE ENGINE SHUTS OFF. THIS HAS HAPPENED SEVERAL TIMES WHILE DRIVING ON THE FREEWAY AT HIGH SPEED. IT IS A VERY DANGEROUS SITUATION, AS THE CAR QUICKLY DECELERATES AND POWER STEERING NO LONGER WORKS. I HAVE BEEN INCREDIBLY LUCKY TO BE ABLE TO GET TO THE SIDE OF THE HIGHWAY AFTER LOSING POWER EACH TIME (IT HAS HAPPENED ON THE FREEWAY 5 TIMES NOW). THE CAR WILL NOT START AFTER IT LOSES POWER AND PUTS UP A RANDOM CHECK ENGINE ERROR. SOMETIMES, AFTER SITTING FOR A PERIOD OF TIME, IT WILL START UP, BUT THIS SEEMS TO BE COMPLETELY RANDOM, AS IT HAPPENS SOMETIMES, BUT NOT ALWAYS. I HAVE TAKEN THE VEHICLE TO BMW SEVERAL TIMES NOW AND THEY HAVE REPLACED SEVERAL PARTS AND ASSURED ME IT IS FIXED, BUT IT KEEPS HAPPENING. I AM NOW VERY CONCERNED FOR MY FAMILY'S SAFETY. I REALIZE THE CAR IS A 2009 MODEL, AND IT HAS A LITTLE OVER 100,000 MILES ON IT, BUT THIS TYPE OF POWER LOSS SHOULD NOT BE HAPPENING OVER AND OVER AGAIN, ESPECIALLY WHEN IT HAS BEEN TAKEN TO THE BMW DEALER. I HAVE SPECIFIED THE LAST INCIDENT IN THE "WHEN DID THIS HAPPEN" QUESTION BELOW, BUT THE PROBLEM STARTED ABOUT 6 WEEKS AGO.
NHTSA ODI #10983375
83,000 miles · May 9, 2016
Fuel/propulsion System
DRIVING ALONG AT 80 MPH ON THE EXPRESSWAY IN RUSH HOUR TRAFFIC, HEADING INTO A CURVE. CRUISE CONTROL WAS ACTIVATED, SERVICE ENGINE LIGHT CAME ON, AND CAR SHUTOFF. WAS ABLE TO ACTIVATE HAZARDS AND MANEUVER BETWEEN THE CAR AND SEMI NEXT TO ME TO GET TO RIGHT SHOULDER. (DITCH ON LEFT SIDE) ONCE SAFELY OFF THE SIDE OF THE ROAD TRIED…
Read full complaint
DRIVING ALONG AT 80 MPH ON THE EXPRESSWAY IN RUSH HOUR TRAFFIC, HEADING INTO A CURVE. CRUISE CONTROL WAS ACTIVATED, SERVICE ENGINE LIGHT CAME ON, AND CAR SHUTOFF. WAS ABLE TO ACTIVATE HAZARDS AND MANEUVER BETWEEN THE CAR AND SEMI NEXT TO ME TO GET TO RIGHT SHOULDER. (DITCH ON LEFT SIDE) ONCE SAFELY OFF THE SIDE OF THE ROAD TRIED TO RESTART AND CAR CRANKED BUT DID NOT START. JUST HAD FUEL PUMP REPLACED 6 WEEKS AGO FOR SAME CRANKING, BUT NOT STARTING BEHAVIOR. BMW HAS CONFIRMED THE NEW HPFP THEY PUT IN 6 WEEKS AGO FAILED.
NHTSA ODI #10863867
91,000 miles · Dec 9, 2015
EngineFuel/propulsion SystemPower Train
I HAD JUST LEFT HOME AND HAD BEEN DRIVING FOR FEW MINUTES. WAS WAITING ON TOP OF A SMALL HILL AT A STOP LIGHT AND STARTED TO ACCELERATE WHEN IT TURNED GREEN. THAT IS WHEN THE CAR TURNED OFF AND STARTED TO ROLL BACKWARD DOWN A HILL. HAD TO PUT ON EMERGENCY BRAKE AND TRIED TO TURN ON THE CAR BUT NOTHING HAPPENED. SO HAD TO CRUI…
Read full complaint
I HAD JUST LEFT HOME AND HAD BEEN DRIVING FOR FEW MINUTES. WAS WAITING ON TOP OF A SMALL HILL AT A STOP LIGHT AND STARTED TO ACCELERATE WHEN IT TURNED GREEN. THAT IS WHEN THE CAR TURNED OFF AND STARTED TO ROLL BACKWARD DOWN A HILL. HAD TO PUT ON EMERGENCY BRAKE AND TRIED TO TURN ON THE CAR BUT NOTHING HAPPENED. SO HAD TO CRUISE BACKWARDS TO THE SIDE OF THE ROAD. POWER STEERING WAS NOT WORKING AND WAS DIFFICULT TO STEER. AFTER WATING 10 MINUTES TRIED TO RESTART CAR AGAIN AND IT TURNED ON. BROUGHT THE CAR IN TO THE BMW DEALERSHIP AND THEY SAID THEY COULD FIND ANYTHING WRONG WITH THE CAR. NOW 4 MONTHS LATER MY CAR IS NOT WORKING AT ALL.
NHTSA ODI #10809309
114,000 miles · Jul 27, 2015
Fuel/propulsion System
THE ENGINE SHUT DOWN WHILE DRIVING IN TRAFFIC. ONLY AFTER DISENGAGING THE KEY AND WAITING ABOUT 30 MINUTES, THE VEHICLE CAN START UP AGAIN. IF THE PROBLEM IS NOT ADDRESSED, THIS EVENT WILL HAPPEN WITHIN ABOUT A DAY TO A WEEK. I DROVE THE VEHICLE DAILY ON MY COMMUTE TO WORK. THIS PROBLEM HAS ALWAYS OCCURRED ON MY RETURN TRIP …
Read full complaint
THE ENGINE SHUT DOWN WHILE DRIVING IN TRAFFIC. ONLY AFTER DISENGAGING THE KEY AND WAITING ABOUT 30 MINUTES, THE VEHICLE CAN START UP AGAIN. IF THE PROBLEM IS NOT ADDRESSED, THIS EVENT WILL HAPPEN WITHIN ABOUT A DAY TO A WEEK. I DROVE THE VEHICLE DAILY ON MY COMMUTE TO WORK. THIS PROBLEM HAS ALWAYS OCCURRED ON MY RETURN TRIP IN THE AFTERNOON. THE ERROR CODES THAT SHOWED UP WERE: A GENERIC CODE FOR THE FUEL PUMP, FUEL MODULE CONTROL VOLTAGE TOO HIGH, AND FUEL MODULE CONTROL CURRENT TOO LOW. AFTER TWO TRIPS TO WEATHERFORD BMW, THE PROBLEM WAS TENTATIVELY SOLVED. ON MY FIRST VISIT, THEY MISDIAGNOSED THE PROBLEM TO BE THAT THE FUEL MODULE CONTROL VOLTAGE WAS OUT OF CALIBRATION. THEY SUPPOSEDLY RECALIBRATED IT, TEST DROVE IT, AND SOLVED THE PROBLEM. THEY CHARGED ME THE $210 DIAGNOSTIC FEE BECAUSE THEY CLAIMED THIS WAS NOT A WARRANTY ISSUE. HOWEVER, THE SAME PROBLEM OCCURRED THE NEXT DAY ON MY AFTERNOON COMMUTE. AFTER BRINGING MY CAR BACK TO THEM. THEY DIAGNOSED THE PROBLEM TO BE A FAULTY FUEL PUMP CONTROL MODULE (EKPS MODULE). THE REPAIR WAS COVERED UNDER THE SULEV WARRANTY FOR BMW VEHICLES WITH THE N51 ENGINE. THEY DID NOT CHARGE ME THIS TIME, BUT THEY REFUSED TO CREDIT THE CHARGE ON MY FIRST VISIT, SAYING THAT THEY WOULD HAVE HAD TO RECALIBRATE THE VOLTAGE ANYWAY. I CONTENDED THAT THE FAULTY MODULE CAUSED THE VOLTAGE TO BE OUT OF CALIBRATION AND THAT A FUNCTIONAL REPLACEMENT MODULE WOULD HAVE BROUGHT THE VOLTAGE BACK WITHIN SPECIFICATION, AND THAT IF THEY HAD JUST REPLACED THE MODULE ON MY FIRST VISIT THAT THEY WOULD NOT HAVE HAD TO RECALIBRATE THE VOLTAGE. HOWEVER, WEATHERFORD BMW INSISTED ON NOT REFUNDING THE CHARGE FOR THE FIRST VISIT, AND I HAVE FILED A CLAIM WITH MY CREDIT CARD COMPANY TO DISPUTE THE CHARGE.
NHTSA ODI #10743979
Mileage unknown · Jul 27, 2015
Fuel/propulsion System
THE VEHICLE WAS PARKED BUT STILL RUNNING. AN ERROR MESSAGE "FUEL PUMP FAILURE" POPPED UP ON SCREEN AND THE "CHECK ENGINE LIGHT" TURNED ON; THE CAR TURNED OFF. THE CAR HAS NOT BEEN ABLE TO RESTART. IT SHOULD BE NOTED THAT I TOOK THE CAR IN FOR SERVICE LESS THAN TWO WEEKS PRIOR.
NHTSA ODI #10743746
29,520 miles · Sep 9, 2014
Electrical SystemFuel/propulsion System
PURCHASED THE CAR USED APPX 4 MONTHS AGO WITH JUST UNDER 25K MILES. LAST WEEK WHILE DRIVING IN TRAFFIC APPX 45 - 50 MPH THE CAR STARTED TO SKIP AND LOSE FORWARD POWER. WHILE WAITING FOR A TOW TRUCK THE CAR JUST LOST ALL ELECTRICAL POWER AS WELL. I COULD HEAR RELAYS CLICKING BUT NOTHING WORKED. AT THE SHOP (NON-BMW) TO BE EVA…
Read full complaint
PURCHASED THE CAR USED APPX 4 MONTHS AGO WITH JUST UNDER 25K MILES. LAST WEEK WHILE DRIVING IN TRAFFIC APPX 45 - 50 MPH THE CAR STARTED TO SKIP AND LOSE FORWARD POWER. WHILE WAITING FOR A TOW TRUCK THE CAR JUST LOST ALL ELECTRICAL POWER AS WELL. I COULD HEAR RELAYS CLICKING BUT NOTHING WORKED. AT THE SHOP (NON-BMW) TO BE EVALUATED I HAD TO PURCHASE A NEW BATTERY (THIS REPLACED THE ORIGINAL). FINAL EVALUATION WAS THAT THE FUEL PUMP NEEDED TO BE REPLACED WHICH I HAVE NOW PAID FOR OUT OF POCKET. I AM AFRAID THAT THERE IS SOME ELECTRICAL ISSUE LURKING AS WELL, BUT SO FAR THE CAR IS DRIVING WELL. SINCE I PURCHASED THE CAR USED I WAS NOT AWARE OF ANY RECALLS BUT NOW I HAVE SEARCHED BY VIN AND FOUND THE RECALL ON THE BATTERY CABLE AND HAVE THAT SCHEDULED. 29,520 MILES IS TOO SOON TO NEED A FUEL PUMP REPLACEMENT! *TR
NHTSA ODI #10631908
40,000 miles · May 24, 2014
Fuel/propulsion System
AS I WAS DRIVING MY CAR NORMALLY MY CAR JUST TURNED OFF ON ME WHILE GOING 50. ITS TELLING ME ON THE SCREEN ITS THE FUEL PUMP. *TR
NHTSA ODI #10593875
67,000 miles · Apr 19, 2013
Fuel/propulsion System
I WAS DRIVING SOUTH ON RTE 495 IN MA IN THE LEFT LANE AND HAD JUST PASSED THE EXIT RAMP TO RTE 3 WHEN THE CAR SEIZED AND DRAMATICALLY SLOWED DOWN, I WAS GOING 70-75 MPH WITH OTHER CARS BEHIND AND NEXT TO ME GOING THE SAME SPEED. IT'S ONLY DUE TO THE ALERTNESS OF THE DRIVER BEHIND ME THAT BOTH OF US ARE NOT DEAD. HE SWERVED INTO …
Read full complaint
I WAS DRIVING SOUTH ON RTE 495 IN MA IN THE LEFT LANE AND HAD JUST PASSED THE EXIT RAMP TO RTE 3 WHEN THE CAR SEIZED AND DRAMATICALLY SLOWED DOWN, I WAS GOING 70-75 MPH WITH OTHER CARS BEHIND AND NEXT TO ME GOING THE SAME SPEED. IT'S ONLY DUE TO THE ALERTNESS OF THE DRIVER BEHIND ME THAT BOTH OF US ARE NOT DEAD. HE SWERVED INTO THE MIDDLE LANE AND WENT BY ME. AFTER THAT I CROSSED THREE LINES OF TRAFFIC GOING AT 10-20 MPH ON A MAJOR HIGHWAY. I SURVIVED THE EXPERIENCE, BUT I FEEL IT IS MY RESPONSIBILITY TO REPORT THIS INCIDENT AND HOPEFULLY SAVE THE LIFE OF SOMEBODY ELSE IN THE FUTURE IF BMW CAN BE COMPELLED TO FIX THEIR FUEL PUMP ISSUE ON THE 328I. I CALLED BMW AS I WAS WAITING FOR A TOW AND WAS TOLD THAT THERE'S A RECALL ON THE 335'S FUEL PUMP, BUT NOT ON THE 328I. I BELIEVE ONLY A DEATH WILL COMPEL THEM TO TAKE ACTION. AS FOR ME, I PAID THE BMW DEALERSHIP IN SUDBURY, MA $800 TO REPLACE THE FUEL PUMP AND DROVE THE CAR STRAIGHT TO A MAZDA DEALERSHIP AND TRADED IT FOR A CX-5 BECAUSE I BELIEVE THE BMW IS UNSAFE AND A POSSIBLE DEATH TRAP. *TR
NHTSA ODI #10508878
Official recalls
6Jul 3, 2024
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags:frontal
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jun 19, 2019
BMW of North America, LLC (BMW) is recalling certain 2009 328i and 328xi, 2009-2011 335d, 2008-2012 M3 Coupe and M3 Convertible, and 2008-2011 M3 Sedan vehicles. The connection of the positive battery cable at the fuse box terminal may degrade, resulting in an intermittent loss of electrical power.
Consequence & remedy
Consequence: A loss of electrical power can cause the vehicle to stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace and secure the positive battery cable connector, free of charge. The recall began August 14, 2019. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall is an expansion of a previous recall, number 18V-314.
Additional source detail variants (3)
Electrical System:wiring:fuses And Circuit Breakers
BMW of North America, LLC (BMW) is recalling certain 2009 328i and 328xi, 2009-2011 335d, 2008-2012 M3 Coupe and M3 Convertible, and 2008-2011 M3 Sedan vehicles. The connection of the positive battery cable at the fuse box terminal may degrade, resulting in an intermittent loss of electrical power.
Consequence: A loss of electrical power can cause the vehicle to stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace and secure the positive battery cable connector, free of charge. The recall began August 14, 2019. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall is an expansion of a previous recall, number 18V-314.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW of North America, LLC (BMW) is recalling certain 2009 328i and 328xi, 2009-2011 335d, 2008-2012 M3 Coupe and M3 Convertible, and 2008-2011 M3 Sedan vehicles. The connection of the positive battery cable at the fuse box terminal may degrade, resulting in an intermittent loss of electrical power.
Consequence: A loss of electrical power can cause the vehicle to stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace and secure the positive battery cable connector, free of charge. The recall began August 14, 2019. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall is an expansion of a previous recall, number 18V-314.
Electrical System
BMW of North America, LLC (BMW) is recalling certain 2009 328i and 328xi, 2009-2011 335d, 2008-2012 M3 Coupe and M3 Convertible, and 2008-2011 M3 Sedan vehicles. The connection of the positive battery cable at the fuse box terminal may degrade, resulting in an intermittent loss of electrical power.
Consequence: A loss of electrical power can cause the vehicle to stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace and secure the positive battery cable connector, free of charge. The recall began August 14, 2019. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall is an expansion of a previous recall, number 18V-314.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 25, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Consequence & remedy
Consequence: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
Remedy: BMW will notify owners, and dealers will replace the wiring and electrical connectors, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact BMW customer service at 1-800-525-7417.
Feb 7, 2013
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence & remedy
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Additional source detail variants (3)
Electrical System:wiring:fuses And Circuit Breakers
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical System
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration