NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
6 reportsClear category filter165,000 miles · Jul 10, 2023
Fuel System, Gasoline
The contact owns a 2007 BMW 328I. The contact stated that while driving at an undisclosed speed, he smelled fuel within the interior of the vehicle and observed low RPM's before the vehicle lost motive power and stalled. The contact was able to coast to the shoulder of the road, where, after visual inspection, he observed fuel l…
Read full complaint
The contact owns a 2007 BMW 328I. The contact stated that while driving at an undisclosed speed, he smelled fuel within the interior of the vehicle and observed low RPM's before the vehicle lost motive power and stalled. The contact was able to coast to the shoulder of the road, where, after visual inspection, he observed fuel leaking within the rear driver's side wheel well. The check engine warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was towed to the residence. The vehicle was not repaired. The manufacturer was notified of the failure but was unable to help. The failure mileage was 165,000.
NHTSA ODI #11531405
71,000 miles · Dec 27, 2011
Fuel System, Gasoline
SENSOR IN FUEL TANK DID NOT REPORT AMOUNT OF GAS IN TANK TO DASH. CAR DID NOT HAVE ANY GAS BUT REPORTED A QUARTER TANK. WHILE DRIVING AT ROUGHLY 45 MILES AN HOUR, CAR SUDDENLY DIED IN CENTER LANE. BARELY HAD ENOUGH TIME TO PULL OVER. THE WORST PART IS I WAS ABOUT TO ENTER THE HIGHWAY AND MY SPEED WOULD HAVE BEEN ROUGHLY 70-75 MP…
Read full complaint
SENSOR IN FUEL TANK DID NOT REPORT AMOUNT OF GAS IN TANK TO DASH. CAR DID NOT HAVE ANY GAS BUT REPORTED A QUARTER TANK. WHILE DRIVING AT ROUGHLY 45 MILES AN HOUR, CAR SUDDENLY DIED IN CENTER LANE. BARELY HAD ENOUGH TIME TO PULL OVER. THE WORST PART IS I WAS ABOUT TO ENTER THE HIGHWAY AND MY SPEED WOULD HAVE BEEN ROUGHLY 70-75 MPH. ON A HIGHWAY, HAD MY CAR DIED IN THE SAME MANNER MY SAFETY WOULD HAVE BEEN COMPROMISED! I ENDED UP BLOCKING A STREET WITH ONCOMING TRAFFIC AND WAS UNABLE TO MOVE CAR ALONE. DEALERSHIP STATED THE SENSOR IS A PART OF THE WHOLE TANK AND THE TANK MUST BE REPLACED. HOWEVER, BECAUSE IT IS A SENSOR ISSUE MIGHT HAVE TO BE REPLACED AGAIN IN THE FUTURE. THIS IS DEFECT! *TR
NHTSA ODI #10441396
780,000 miles · Aug 16, 2011
Electronic Stability Control (esc)Engine And Engine CoolingEquipment
I HAVE AN 2007 328I BMW WHICH STALLED AND CUTOFF ON 3 OCCASION WITHIN 4 YEARS. THEY REPLACED AS PER TECH THE FUEL INJECTION TWICE WITHIN 2 YEARS AND NOW THE CAR IS PARKED MY WARRANTY IS EXPIRED AND CUTOFF AGAIN LAST 2 WEEKS. *KB
NHTSA ODI #10419747
50,000 miles · May 18, 2011
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2007 BMW 328I. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH THE VEHICLE WOULD SUDDENLY STALL WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER AND THEY ADVISED HIM THAT THE FUEL PUMP HAD FAILED. THE VEHICLE WAS REPAIRED. A FEW DAYS LATER THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE VEHIC…
Read full complaint
TL*THE CONTACT OWNS A 2007 BMW 328I. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH THE VEHICLE WOULD SUDDENLY STALL WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER AND THEY ADVISED HIM THAT THE FUEL PUMP HAD FAILED. THE VEHICLE WAS REPAIRED. A FEW DAYS LATER THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER AND THEY ADVISED HIM THAT THERE WAS A LOOSE CONNECTION IN THE FUEL TANK. THE VEHICLE WAS REPAIRED AGAIN BY CONNECTING THE TANK IN PLACE. THE VEHICLE SUDDENLY STALLED A THIRD TIME AND IT WAS TOWED TO THE SAME DEALER WHO ADVISED HIM THAT THE FUEL GAUGE WASN'T WORKING AND HE DIDN'T HAVE ANY GASOLINE IN THE TANK. THE FUEL GAUGE WAS REPAIRED. THE FAILURE OCCURRED AGAIN AND THE CONTACT WAS WAITING TO FOR THE DIAGNOSIS. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.
NHTSA ODI #10401428
400 miles · Jul 27, 2010
Fuel System, Gasoline
I HAD JUST PURCHASED A BRAND NEW BMW 328I. WE WERE DRIVING ON I-5 FROM LOS ANGELES TO SAN FRANCISCO. I WAS ACCOMPANIED BY MY HUSBAND AND TWO DOGS. WE WERE TRAVELING ~80 MILES PER HOUR IN THE LEFT LANE. ALL OF THE SUDDEN AND WITHOUT WARNING, THE ENGINE TURNED COMPLETELY OFF ON THE VEHICLE. I LOST POWER STEERING AND BREAKING …
Read full complaint
I HAD JUST PURCHASED A BRAND NEW BMW 328I. WE WERE DRIVING ON I-5 FROM LOS ANGELES TO SAN FRANCISCO. I WAS ACCOMPANIED BY MY HUSBAND AND TWO DOGS. WE WERE TRAVELING ~80 MILES PER HOUR IN THE LEFT LANE. ALL OF THE SUDDEN AND WITHOUT WARNING, THE ENGINE TURNED COMPLETELY OFF ON THE VEHICLE. I LOST POWER STEERING AND BREAKING AND HAD NO OTHER OPTION THAN TO GLIDE INTO THE CENTER MEDIAN. UNFORTUNATELY, THERE WAS NOT SUFFICIENT ROOM FOR THE VEHICLE, SO THE RIGHT TIRES WERE IN THE LEFT LANE OF TRAFFIC. WE CALLED BMW ASSIST, BUT THEY SAID THEY WOULD NOT PICK US UP BECAUSE WE HAD DOGS IN THE CAR. WE WERE STUCK IN THE MEDIAN FOR NEARLY ONE HOUR, AROUND A BEND IN THE FREEWAY, WHERE OTHER CARS COULD NOT SEE US WELL UNTIL THE LAST MINUTE. A CALIFORNIA STATE TROOPER TOGETHER WITH A TOW TRUCK FINALLY RESCUED US FROM THE CENTER MEDIAN. HE SAID WE WERE IN GRAVE DANGER, WHICH WE OBVIOUSLY KNEW. AFTER THE INCIDENT I CALLED THE BEVERLY HILLS BMW DEALERSHIP, WHERE WE PURCHASED THE VEHICLE, AND SPOKE WITH THE MANAGER AND REPORTED THE ISSUE TO BMW ASSIST. I WAS FURIOUS THAT A VEHICLE WOULD TURN OFF AT THAT SPEED. THEY TOLD ME THEY WOULD DOCUMENT THE CLAIM BUT THAT NO OTHER INCIDENCES OF THIS HAD BEEN REPORTED. THE LATTER IS INACCURATE, AS MANY PEOPLE APPARENTLY HAVE HAD THE EXACT SAME ISSUE. *TR
NHTSA ODI #10345766
Mileage unknown · Jun 24, 2008
Fuel System, Gasoline
FUEL PUMP FAILURE. *TR
NHTSA ODI #10232168
Official recalls
6Jul 3, 2024
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags:frontal
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 25, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Consequence & remedy
Consequence: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
Remedy: BMW will notify owners, and dealers will replace the wiring and electrical connectors, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact BMW customer service at 1-800-525-7417.
Nov 12, 2013
BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model year 2006-2007 750i, 750Li, and 760Li sedans, and model year 2006 X5 sports activity vehicles, equipped with certain seat types. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners with an interim notification letter in January 2014 since parts are not currently available. When parts are available, BMW sent a second letter in August and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, free of charge. Additionally, owners of model year 2006-2007 3 Series with standard seats, 5 Series with comfort seats, and Z4 models, will receive an extended warranty on their front passenger seat occupant detection mat. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Feb 7, 2013
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence & remedy
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Additional source detail variants (3)
Electrical System:wiring:fuses And Circuit Breakers
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical System
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration