Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1125–50K
2150–75K
1975–100K
22100–150K
10150K+
90 reports with mileage · 72 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports19 fire reports7 injury reports
What owners actually said
162 reports
129,000 miles · Feb 2, 2010
Exterior Lighting
APPROX TEN MONTHS AGO THE PASSENGER SIDE TAIL LIGHT STARTED MALFUNCTIONING INTERMITTENTLY. TOOK CAR TO DEALERSHIP AND THEY REPLACED ALL OF THE LIGHT BULBS...WITHIN TWO DAYS THE ENTIRE LIGHT FIXTURE STOPPED WORKING COMPLETELY AND HAS NOT WORKED SINCE. THE DRIVER SIDE TAIL LIGHT STOPPED FUNCTIONING FOUR MONTHS LATER. BOTH LIGHT…
Read full complaint
APPROX TEN MONTHS AGO THE PASSENGER SIDE TAIL LIGHT STARTED MALFUNCTIONING INTERMITTENTLY. TOOK CAR TO DEALERSHIP AND THEY REPLACED ALL OF THE LIGHT BULBS...WITHIN TWO DAYS THE ENTIRE LIGHT FIXTURE STOPPED WORKING COMPLETELY AND HAS NOT WORKED SINCE. THE DRIVER SIDE TAIL LIGHT STOPPED FUNCTIONING FOUR MONTHS LATER. BOTH LIGHT FIXTURES HAVE NOT WORKED (TURN SIGNAL, TAIL LIGHT AND BRAKE LIGHT) SINCE SEPTEMBER 2009. I TOOK THE CAR TO THE DEALERSHIP IN NOVEMBER AND WAS TOLD THAT THERE WAS A MANUFACTURER'S DEFECT IN THE LIGHT FIXTURES. THE ESTIMATED COST TO FIX BOTH TAIL LIGHTS WAS $450.00. I WAS TOLD EVENTHOUGH THE DEALERSHIP WAS AWARE THE PROBLEM WAS A MANUFACTURER'S DEFECT THERE WAS NO RECALL ISSUED SO I WOULD BE RESPONSIBLE FOR THE FULL COST OF THE REPAIR. THE DEALERSHIP WAS UNWILLING TO NEGOTIATE THE COST ESTIMATE. I REQUESTED A WRITTEN ESTIMATE, WHICH THE SERVICE DEPARTMENT HAND WROTE ON A PIECE OF PAPER (DEALERSHIP USUALLY PRINTS OFF COMPUTER). I KEEP THIS IN THE GLOVE BOX TO SHOW LAW ENFORCEMENT WHENEVER THEY PULL ME OVER FOR INOPERABLE REAR LIGHTS. I READ THAT BMW ISSUED A TECHNICAL BULLETIN TO ADD GROUND WIRES TO REPAIR THE PROBLEM. I FEEL THAT $450 IS AN UNREASONABLE FEE TO BE CHARGED TO ADD GROUND WIRES TO AN EASILY ACCESSIBLE LOCATION IN THE TRUNK OF THE CAR. *TR
NHTSA ODI #10303940
Mileage unknown · Jan 21, 2010
Visibility
TL*THE CONTACT OWNS A 2002 BMW 325I. HE STATED THAT THE ELECTRONIC WINDOWS BROKE INSIDE OF THE DOOR THREE TIMES. ON TWO OCCASIONS THE VEHICLE WAS REPAIRED AT THE OWNERS EXPENSE. THE THIRD AND MOST RECENT FAILURE HAS NOT BEEN REPAIRED. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN SO THAT THEY COULD DIAGNOSE THE FAILURE.…
Read full complaint
TL*THE CONTACT OWNS A 2002 BMW 325I. HE STATED THAT THE ELECTRONIC WINDOWS BROKE INSIDE OF THE DOOR THREE TIMES. ON TWO OCCASIONS THE VEHICLE WAS REPAIRED AT THE OWNERS EXPENSE. THE THIRD AND MOST RECENT FAILURE HAS NOT BEEN REPAIRED. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN SO THAT THEY COULD DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 76000.
NHTSA ODI #10301735
70,000 miles · Dec 30, 2009
Exterior LightingFire
TL* THE CONTACT OWNS A 2002 BMW 325I PURCHASED NEW IN 2002. THE TAIL LIGHTS AND THE DRIVER- SIDE HEADLIGHT ON THE VEHICLE FAILED INTERMITTENTLY. A TECHNICIAN FROM THE DEALER NOTICED THAT THE WIRE FOR THE HEADLIGHT ASSEMBLY AND THE GROUND WIRE HAD BURNED. THE DEALER ADVISED REPLACING THE ENTIRE HEAD LIGHT ASSEMBLY AT AN EXPEN…
Read full complaint
TL* THE CONTACT OWNS A 2002 BMW 325I PURCHASED NEW IN 2002. THE TAIL LIGHTS AND THE DRIVER- SIDE HEADLIGHT ON THE VEHICLE FAILED INTERMITTENTLY. A TECHNICIAN FROM THE DEALER NOTICED THAT THE WIRE FOR THE HEADLIGHT ASSEMBLY AND THE GROUND WIRE HAD BURNED. THE DEALER ADVISED REPLACING THE ENTIRE HEAD LIGHT ASSEMBLY AT AN EXPENSE OF $600. NO REPAIRS WERE MADE. THE FAILURE AND CURRENT MILEAGES WERE UNDER 70,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10297581
107,000 miles · Dec 15, 2009
Exterior LightingFire
BRAKE LIGHT FAILURE CAME ON IN MY 2002 BMW325I. I WENT OUT TO LOOK FOR THE FAILED BULB, BUT THE BRAKE LIGHTS WERE ALL WORKING. I NOTICED THAT THE LEFT SIDE, REAR LIGHTS WERE MUCH DIMMER THAN THE RIGHT SIDE. I WENT TO THE MECHANIC AND HE SHOWED ME A BURNT WIRE AND MOLTEN PLASTIC CONNECTOR FROM THE REAR LIGHT CLUSTER. HE SAI…
Read full complaint
BRAKE LIGHT FAILURE CAME ON IN MY 2002 BMW325I. I WENT OUT TO LOOK FOR THE FAILED BULB, BUT THE BRAKE LIGHTS WERE ALL WORKING. I NOTICED THAT THE LEFT SIDE, REAR LIGHTS WERE MUCH DIMMER THAN THE RIGHT SIDE. I WENT TO THE MECHANIC AND HE SHOWED ME A BURNT WIRE AND MOLTEN PLASTIC CONNECTOR FROM THE REAR LIGHT CLUSTER. HE SAID THAT THIS IS A KNOWN PROBLEM WITH THIS CAR BECAUSE BMW DID NOT PROVIDE ENOUGH GROUND TO THE CLUSTER AND OVERTIME THE EXTRA HEAT GENERATED BY THE CURRENT WILL BURN THE WIRE AND CONNECTOR. AT OTHER TIMES, HE SAID, THE CONNECTOR WILL SHORT THE GND PIN TO THE PINS AROUND IT AND CAUSES SMALL FIRES. BMW HAS A SIB NUMBER 63 03 06 OUT FOR THIS PROBLEM AND THEY HAVE THE GUTS TO CHARGE CUSTOMERS $400 TO REPAIR THEIR OWN MISTAKE. I THINK THIS IS A SERIOUS SAFETY VIOLATION AND I BELIEVE THAT BMW SHOULD BE HELD ACCOUNTABLE BY FIXING ALL THE CARS OUT THERE WITH THIS KNOWN DEFECT. TODAY, I SAW THE SAME THING HAPPENING TO A 2008 BMW 550 AT THIS LINK: HTTP://FORUMS.5SERIES.NET/INDEX.PHP?SHOWTOPIC=90746&ST=0&P=1073957&#ENTRY1073957 PLEASE INVESTIGATE AND KEEP PEOPLE SAFE. THANK YOU.*TR
NHTSA ODI #10295804
135,000 miles · Dec 14, 2009
Power Train
BMW 2002 325I WITH 135K MILES ON IT REVERSE GEAR DOES NOT WORK. I STARTED MY CAR LET IT IDLE FOR 3-5 MINUTES SINCE THE TEMPERATURE OUTSIDE WAS COLD. I SHIFTED INTO REVERSE GEAR, AND NOTHING HAPPENED. I HAD JUST PARKED THE CAR APPROXIMATELY 2 HOURS EARLIER. THERE WAS NO INDICATION PRIOR TO THIS INCIDENT THAT THERE WAS A PROBLE…
Read full complaint
BMW 2002 325I WITH 135K MILES ON IT REVERSE GEAR DOES NOT WORK. I STARTED MY CAR LET IT IDLE FOR 3-5 MINUTES SINCE THE TEMPERATURE OUTSIDE WAS COLD. I SHIFTED INTO REVERSE GEAR, AND NOTHING HAPPENED. I HAD JUST PARKED THE CAR APPROXIMATELY 2 HOURS EARLIER. THERE WAS NO INDICATION PRIOR TO THIS INCIDENT THAT THERE WAS A PROBLEM WITH THE TRANSMISSION. ON THE NEXT MORNING I CALLED THE LOCAL BMW DEALERSHIP AND EXPLAINED WHAT HAD HAPPENED. THEY STATED THAT I NEEDED TO REPLACE THE TRANSMISSION. HOW CAN YOU DETERMINE THAT FROM A PHONE CONVERSATION, I WONDERED. I PUSHED THE CAR OUT OF MY GARAGE AND PROCEEDED TO A MECHANIC. WHEN I COMPLETED MY DIALOGUE OF WHAT HAD OCCURRED HE RESPONDED THAT I WAS NUMBER 4 FOR HIM THIS YEAR. A REPLACEMENT TRANSMISSION COST BETWEEN $3K - $5K. I RETURNED HOME AND BEGAN MY UNOFFICIAL INTERNET RESEARCH...I AM NOT ALONE AND BMW OF NA IS DOING NOTHING TO ADDRESS THE MANUFACTURER'S DEFECT. I CONSIDER THIS A SAFETY ISSUE. SUPPOSE I WAS 100S OF MILES AWAY OR IF I WAS IN A POSITION WHERE I NEED TO USE REVERSE TO GET OUT OF HARMS WAY AND IT DID NOT WORK. AS OTHER BMW OWNERS HAVE STATED, AT LEAST MY CHEVY OR FORD USED TO TELL ME THAT IT WAS SICK AND NEEDED SOME ATTENTION. BMW HAS NO MAINTENANCE REQUIREMENT FOR THIS TRANSMISSION. I AM ASSUMING THAT THEY THINK IT IS REPLACE UPON FAILURE. UNACCEPTABLE, THE PART THAT FAILED IS CALLED THE DRUM. A BAND BREAKS AND THE REVERSE GEAR IS BROKEN. THEY HAVE MODIFIED THE MATERIALS IN THE NEWER DRUMS TO ALLEVIATE THE PROBLEM . THAT TELLS ME THAT THEY ARE AWARE THAT THE MATERIAL THEY INSTALLED IN MY VEHICLE WAS INADEQUATE. I HAVE NOT REPAIRED THE VEHICLE AT THIS TIME STILL SHOPPING AROUND FOR OPTIONS. THIS IS A SAFETY ISSUE AND A RECALL IS WARRANTED. *TR
NHTSA ODI #10295554
10,100 miles · Nov 18, 2009
Electrical SystemExterior Lighting
2002 BMW 325I REAR TAILLIGHTS HAVE FAILED ON BOTH SIDES DUE TO THE WIRING ON BOTH SIDES OF THE HARNESS HAVE EITHER MELTED AND GROUND TO THE OTHER WIRES OR MELTED THE TABS OFF OF THE MALE PLUG. *TR
NHTSA ODI #10292836
68,000 miles · Nov 4, 2009
Electrical System
THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE CAR IS IN DRIVE. *TR
NHTSA ODI #10290976
62,000 miles · Jul 22, 2009
Exterior Lighting
REAR TAIL BRAKE LIGHT INTERMITTENTLY WORKS ON AND OFF, HAVE REPLACED THE LIGHT AND THIS DIDN'T FIX IT. HAVEN'T HAD AN ACCIDENT YET, BUT ARE TAKING IT IN TO THE DEALER TO BE REPAIRED ASAP . SAW THAT BMW HAS A SERVICE BULLETIN OUT REGARDING THIS PROBLEM. *TR STARTED FAILING 2 MONTHS AGO AND EACH TIME I OPEN TRUNK AND REMOVE BUL…
Read full complaint
REAR TAIL BRAKE LIGHT INTERMITTENTLY WORKS ON AND OFF, HAVE REPLACED THE LIGHT AND THIS DIDN'T FIX IT. HAVEN'T HAD AN ACCIDENT YET, BUT ARE TAKING IT IN TO THE DEALER TO BE REPAIRED ASAP . SAW THAT BMW HAS A SERVICE BULLETIN OUT REGARDING THIS PROBLEM. *TR STARTED FAILING 2 MONTHS AGO AND EACH TIME I OPEN TRUNK AND REMOVE BULB -IT SEEMS TO WORK FOR A WHILE THEN OUT AGAIN. *TR
NHTSA ODI #10277899
98,000 miles · Jun 26, 2009
Engine And Engine CoolingFire
I WAS DRIVING MY CAR WHEN I SAW SMOKE FROM UNDER THE HOOD. THE CAR WAS NOT OVERHEATING AND I PULLED OVER, OPENED THE HOOD AND THE WIRES CONNECTING TO THE COOLING FAN HAD CAUSED THE PLASTIC TO START ON FIRE. LUCKILY I WAS PAYING ATTENTION AND HAD ACCESS TO A FIRE EXTINGUISHER AND WAS ABLE TO PUT OUT THE FLAMES. *TR
NHTSA ODI #10275043
50,000 miles · Jun 15, 2009
Visibility
REAR WINDOW REGULATOR FAILED. VEHICLE WARRANTY WAS EXPIRED AND WINDOW WAS REPAIRED AT DEALER. OPPOSITE REAR WINDOW REGULATOR FAILED SEVERAL WEEKS LATER. FRONT WINDOW OPERATORS MOVE THE WINDOW SLOWLY AND WINDOWS NEED MANUAL ASSISTANCE (PUSH ON GLASS) TO CLOSE. INVESTIGATED WHETHER NEW WINDOW REGULATOR DESIGN HAS BEEN IMPLEMEN…
Read full complaint
REAR WINDOW REGULATOR FAILED. VEHICLE WARRANTY WAS EXPIRED AND WINDOW WAS REPAIRED AT DEALER. OPPOSITE REAR WINDOW REGULATOR FAILED SEVERAL WEEKS LATER. FRONT WINDOW OPERATORS MOVE THE WINDOW SLOWLY AND WINDOWS NEED MANUAL ASSISTANCE (PUSH ON GLASS) TO CLOSE. INVESTIGATED WHETHER NEW WINDOW REGULATOR DESIGN HAS BEEN IMPLEMENTED. DETERMINED THAT REPLACEMENT WINDOW REGULATORS ARE IDENTICAL TO ORIGINAL. THE DESIGN PROBLEM STEMS FROM THE ATTACHMENT OF THE WINDOW REGULATOR CABLE ENDS INTO PLASTIC RETAINERS. OBVIOUSLY, DURING THE CYCLES OF WINDOW OPERATION, THE PLASTIC IS OVER-STRESSED AND FAILS. PLACED WRITTEN COMPLAINT WITH BMW USA TO NO AVAIL AS THE VEHICLE IS NO LONGER UNDER WARRANTY. FIRST WINDOW FAILURE WAS AROUND 50K MILES. REMAINING WINDOW FAILURES WERE AROUND 90K MILES. *TR
BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PSPI passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the passenger's front air bag, free of charge. The recall began February 13, 2020. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2000 323i sedans, coupes, convertibles, and Sports Wagons; 2000 328i sedans and coupes; 2001-2005 325i sedans, coupes, convertibles, and Sport Wagons; 2001-2005 325xi sedans and Sports Wagons; 2006 325i coupes and convertibles; 2001-2006 330i sedans, coupes, and convertibles; 2001-2005 330xi sedans; and 2001-2006 M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure that could cause the air bag inflator to rupture upon deployment of the air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, excessive internal pressure could cause rupturing of the inflator resulting in metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger side frontal air bag, free of charge. An interim notice was mailed to owners in September 2014. A second notice was mailed when an adequate supply of parts became available, on December 1, 2014. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons, and 2003 X5 3.0i and 4.4i Sports Activity Vehicles. Please note that the 5-series and X5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall began Aug 2016. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall supersedes recall 14V-348 in its entirety. Additionally, vehicles that have had their driver side frontal air bag replaced previously as part of a recall remedy need to have their air bag replaced under this recall as well. Note: On December 17, 2015 BMW removed the model year 2004 X5 3.0i and 4.4i Sports Activity vehicle from this recall. Those vehicles were mistakenly identified as including the air bags that are subject to this recall.
BMW is recalling certain model year 2002-2003 325i, 325xi, 330i, 330xi sedans; 325Ci and 330Ci coupes and convertibles; 325iT and 325xiT Sports Wagons; and M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW intends to issue initial notifications to owners informing them of the safety defect in June 2013. Once replacement parts are available, estimated for July, BMW will notify owners again to contact their dealers and schedule a replacement of the passenger air bag, free of charge. Owners may contact BMW customer service at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICLE'S BODY PANEL, TO STOP WORKING.
Consequence & remedy
Consequence: INTERMITTENT LIGHT OPERATION REDUCES THE ABILITY TO WARN OTHER MOTORISTS OF THE DRIVER'S INTENTIONS. THIS COULD CAUSE A VEHICLE CRASH WITHOUT WARNING.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Additional source detail variants (3)
Exterior Lighting:turn Signal
BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICLE'S BODY PANEL, TO STOP WORKING.
Consequence: INTERMITTENT LIGHT OPERATION REDUCES THE ABILITY TO WARN OTHER MOTORISTS OF THE DRIVER'S INTENTIONS. THIS COULD CAUSE A VEHICLE CRASH WITHOUT WARNING.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Exterior Lighting:brake Lights
BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICLE'S BODY PANEL, TO STOP WORKING.
Consequence: INTERMITTENT LIGHT OPERATION REDUCES THE ABILITY TO WARN OTHER MOTORISTS OF THE DRIVER'S INTENTIONS. THIS COULD CAUSE A VEHICLE CRASH WITHOUT WARNING.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Exterior Lighting:tail Lights
BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICLE'S BODY PANEL, TO STOP WORKING.
Consequence: INTERMITTENT LIGHT OPERATION REDUCES THE ABILITY TO WARN OTHER MOTORISTS OF THE DRIVER'S INTENTIONS. THIS COULD CAUSE A VEHICLE CRASH WITHOUT WARNING.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
ON CERTAIN PASSENGER VEHICLES, DURING THE STRUT MOUNT MANUFACTURING PROCESS, THE THRUST BEARING WAS NOT PROPERLY POSITIONS AND SECURED. IF THE SUSPENSION IS FULLY UNLOADED, THE FRONT STRUT COULD SEPARATE FROM THE UPPER MOUNT.
Consequence & remedy
Consequence: THIS COULD AFFECT VEHICLE HANDLING AND CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH FRONT SPRING STRUT UPPER MOUNTS. OWNER NOTIFICATION BEGAN MARCH 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA09019 · Rear Lamp Illumination
Opened Dec 18, 2009 · Closed Sep 28, 2011
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Additional source detail variants (4)
Exterior Lighting
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:brake Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:tail Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
PE09036 · Rear Lamp Illumination
Opened Aug 7, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Additional source detail variants (4)
Exterior Lighting
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:brake Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:tail Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
2002 BMW 325I Problems, Complaints & Recalls | Skip That Year
Illustration