Electrical SystemEngine And Engine CoolingSeat BeltsFire
TL* THE CONTACT OWNS A 1994 BMW 325I. THE CONTACT STATED THAT THE ODOMETER READING WAS INCORRECT. THE MILEAGE INDICATED THAT THE VEHICLE HAD 28,000 MILES WHEN THE TITLE INDICATED THAT THE MILEAGE WAS 128,000. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR A DIAGNOSTIC TEST. THE DEALER ADVISED THE CONTACT THAT ANOTHER MECHANIC HAD …
Read full complaint
TL* THE CONTACT OWNS A 1994 BMW 325I. THE CONTACT STATED THAT THE ODOMETER READING WAS INCORRECT. THE MILEAGE INDICATED THAT THE VEHICLE HAD 28,000 MILES WHEN THE TITLE INDICATED THAT THE MILEAGE WAS 128,000. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR A DIAGNOSTIC TEST. THE DEALER ADVISED THE CONTACT THAT ANOTHER MECHANIC HAD ALTERED THE ODOMETER. THE CONTACT ALSO NOTICED THAT THE ANTI-FREEZE WAS LEAKING, THE FRONT WINDOWS FOGGED AND THE SEAT BELTS WERE DEFECTIVE. THE VEHICLE WAS AT THE DEALERSHIP AWAITING REPAIR AT THE TIME OF THE COMPLAINT. THE APPROXIMATE MILEAGE WAS APPROXIMATELY 28,000. THE CURRENT MILEAGE WAS UNKNOWN.
NHTSA ODI #10324050
Mileage unknown · Jul 14, 2009
Electrical SystemLatches/locks/linkages
CONSUMER'S WIFE WAS LOCKED IN THEIR 1994 BMW 325I AND THE DOORS WOULD NOT OPEN. *NJ THE CONSUMER STATED THE WINDOWS AND HORN DID NOT WORK EITHER. *JB
NHTSA ODI #10276688
90,000 miles · Feb 18, 2008
Electrical SystemFuel System, Gasoline
FUEL GAUGE INTERMITTENT FAILURE. BMW'S FROM 70'S TO '07 HAVE BEEN NOTED BY OWNERS AS BEING A PERSISTENT PROBLEM. MOST DUE TO FAILURE OF THE SENDING UNITS. MANY OWNERS END UP HAVING THE SENDERS REPLACED MULTIPLE TIMES D/T MULTIPLE FAILURES OF THE SENDING UNITS. MY E36 HAS 2 SENDING UNITS AND I HAVE BEEN STUCK ON THE SIDE OF THE R…
Read full complaint
FUEL GAUGE INTERMITTENT FAILURE. BMW'S FROM 70'S TO '07 HAVE BEEN NOTED BY OWNERS AS BEING A PERSISTENT PROBLEM. MOST DUE TO FAILURE OF THE SENDING UNITS. MANY OWNERS END UP HAVING THE SENDERS REPLACED MULTIPLE TIMES D/T MULTIPLE FAILURES OF THE SENDING UNITS. MY E36 HAS 2 SENDING UNITS AND I HAVE BEEN STUCK ON THE SIDE OF THE ROAD MULTIPLE TIMES. AND THE SAME FOR MANY OTHER OWNERS ON BMW ONLINE BOARDS/FORUMS. I'VE BEEN STUCK IN TRAFFIC WHERE I MERELY MISSED AN ACCIDENT BY MANEUVERING W/O ENGINE POWER. PLEASE LOOK INTO THIS. BMW HAS CONTINUED TO HAVE THESE PROBLEMS AND SHOULD RECALL THE FAILED UNITS THAT JUST KEEP FAILING. *TR
NHTSA ODI #10218447
Mileage unknown · Mar 20, 2002
Electrical System
VEHICLE WILL STALL IN RAIN. DEALER DETERMINED THAT COMPUTER MODULE GOT WET AND VEHICLE WILL EITHER STALL OR NOT START. COMPUTER MODULE HAS BEEN REPLACED 3 TIMES. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1994 BMW 325I Problems, Complaints & Recalls | Skip That Year
Illustration