DT: THE CONTACT STATED VEHICLE OVERHEATED RANDOMLY. THE ENGINE HEAD WAS REPLACED TWICE AND NEEDED TO BE REPLACED AGAIN. THE REPAIRS WERE COSTLY. HOWEVER, THE DEALERSHIP REIMBURSED THE CONSUMER FOR ONE REPAIR, BUT WILL NOT DO IT AGAIN. CONSUMER STATE WHILE DRIVING ON THE HIGHWAY VEHICLE OVERHEATED. THE ENTIRE HEAD OF…
Read full complaint
DT: THE CONTACT STATED VEHICLE OVERHEATED RANDOMLY. THE ENGINE HEAD WAS REPLACED TWICE AND NEEDED TO BE REPLACED AGAIN. THE REPAIRS WERE COSTLY. HOWEVER, THE DEALERSHIP REIMBURSED THE CONSUMER FOR ONE REPAIR, BUT WILL NOT DO IT AGAIN. CONSUMER STATE WHILE DRIVING ON THE HIGHWAY VEHICLE OVERHEATED. THE ENTIRE HEAD OF THE ENGINE HAD TO BE REPLACED. THE SERVICE DEALER DID NOT STATE THE REASON FOR THE VEHICLE OVERHEATING. *AK
NHTSA ODI #10132605
Mileage unknown · Aug 1, 2001
Engine And Engine Cooling
TEMPERATURE GUAGE RISES AND A LARGE AMOUNT OF COOLANT SPILL ENGINE OVERHEATS ENGINE STALLS I REALLY DON'T EXPECT THIS ON A BMW WHY DON'T HELP US WITH THE PROBLEM I'M REALLY DISAPOINTED THEY JUST IGNORE THE PROBLEM.
NHTSA ODI #749542
Mileage unknown · Apr 30, 2001
Engine And Engine Cooling
WHILE DRIVING ON EXPRESSWAY, VEHICLE BEGAN TO OVERHEAT AND RED LIGHT CAME ON, CONSUMER HAD VEHICLE INSPECTED AND WAS ADVISED THAT HEAD GASKET CONTAINED A CRACK WHICH CAUSED COOLANT TO LEAK AND CAUSED SEVERE DAMAGE TO THE ENGINE HEAD, CONSUMER WAS ALSO ADVISED BY REPUTABLE BMW DEALERS THAT VEHICLE WAS DESIGNED WITH A FAULTY PART …
Read full complaint
WHILE DRIVING ON EXPRESSWAY, VEHICLE BEGAN TO OVERHEAT AND RED LIGHT CAME ON, CONSUMER HAD VEHICLE INSPECTED AND WAS ADVISED THAT HEAD GASKET CONTAINED A CRACK WHICH CAUSED COOLANT TO LEAK AND CAUSED SEVERE DAMAGE TO THE ENGINE HEAD, CONSUMER WAS ALSO ADVISED BY REPUTABLE BMW DEALERS THAT VEHICLE WAS DESIGNED WITH A FAULTY PART CALLED THE PROFILE GASKET AND IT IS WELL KNOWN, BUT MANUFACTURER DOES NOT WANT TO RECOGNIZE IT AS A PROBLEM, CONSUMER HAS ALSO EXPERIENCED COOLING SYSTEM PROBLEMS TWICE, THE FIRST REQUIRING THE REPLACEMENT OF THE ENTIRE RADIATOR AND ALSO THERE WAS A RECALL ON RADIATOR CAP. *JB
NHTSA ODI #560955
Mileage unknown · Oct 26, 2000
Engine And Engine Cooling
WHILE DRIVING THE OVER-HEATING LIGHT CAME ON, DEALER FOUND HEAD GASKET TO BE CRACKED, CONSUMER SAYS THERE WAS A DESIGN FLAW TO THE PROFILE GASKET WHICH CAN LEAK AND OVER A PERIOD OF TIME CAUSE SEVERE DAMAGE TO THE ENGINE. *SLC
NHTSA ODI #556440
Mileage unknown · Nov 27, 1996
Engine And Engine Cooling
VEHICLE HAS HAD CONTINUED PROBLEMS WITH ENGINE SHUTTING DOWN, UNABLE TO DETERMINE CAUSE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1994 BMW 318I Problems, Complaints & Recalls | Skip That Year
Illustration