IllustrationFAULTY PROFILE GASKET ON 1992 BMW 318I ENGINE. *AK
1992 BMW 318I
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all 318I years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 8 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Engine And Engine Cooling complaints
5 reportsTHE PROFILE HEAD GASKET IS A WIDELY REPORTED DEFECT ON BMW 318I ENGINES. FOR ME ITS A SERIOUS PROBLME NOW THAT THIS IS THE SECOND HEAD GASKET TO BLOW. THE FIRST WAS REPLACED UNDER WARRANTY, THE SECOND MAY OR MAY NOT BE REPLACED UNDER WARRANTY. IN ANNY EVENT THE REPAIR WORK HAS NOT YET BEEN DONE. BASED ON THE WEB PAGES I HAVE…
Read full complaint
THE PROFILE HEAD GASKET IS A WIDELY REPORTED DEFECT ON BMW 318I ENGINES. FOR ME ITS A SERIOUS PROBLME NOW THAT THIS IS THE SECOND HEAD GASKET TO BLOW. THE FIRST WAS REPLACED UNDER WARRANTY, THE SECOND MAY OR MAY NOT BE REPLACED UNDER WARRANTY. IN ANNY EVENT THE REPAIR WORK HAS NOT YET BEEN DONE. BASED ON THE WEB PAGES I HAVE READ THIS IS A WIDESPREAD PROBLEM AND BMW IS NOT REACTING PROPERLY. I THINK YOU SHOULD CONSIDER A CLASS-ACTION LAW SUIT TO MAKE THEM ACT PROPERLY FOR SUCH A MAJOR DEFECT.
PROFILE GASKET FAILURE. THE PART FAILS ON ALL M42 ENGINES PRODUCED BY BMW BETWEEN 1991 AND 1992. WAS MADE AWARE VIA TECHNICAL BULLLETIN SENT TO DEALERS. A RECALL NEEDS TO BE ISSUED.
I HAVE DONE SOME RESEARCH OVER THE INTERNET FOR THIS PROBLEM AND IT APPEARS TO BE A VERY COMMON ONE. I AM COMPLETELY AMAZED THAT BMW IS NOT COVERING THIS REPAIR OF THIS, EVEN THOUGH THEY ARE AWARE OF THE DEFECT.
VEHICLE EXPERIENCED COOLANT LOSS AND LOW COOLANT LEVELS BUT THE TEMPERATURE GUAGE DID NOT RISE ABOVE NORMAL. LOSS WAS DUE TO ENGINE GASKET FAILURE.
Official recalls
398V178000 · Engine And Engine Cooling:cooling System
Aug 4, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
97V131000 · Vehicle Speed Control
Aug 19, 1997
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
96V110000 · Air Bags:frontal
Jul 1, 1996
THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY CAN BREAK WITHOUT WARNING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CONTACT RING WIRING COULD EVENTUALLY BREAK. THE AIR BAG READINESS INDICATOR LAMP (SRS OR AIRBAG) IN THE INSTRUMENT CLUSTER WILL ILLUMINATE, AND THE AIR BAG WOULD NOT DEPLOY IN THE EVENT OF A FRONTAL IMPACT VEHICLE COLLISION.
Remedy: DEALERS WILL REPLACE THE LOCKING TAB WITH ONE OF A DIFFERENT DESIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.