Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
125–50K
950–75K
875–100K
11100–150K
4150K+
34 reports with mileage · 17 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports3 injury reports
What owners actually said
51 reports
117,000 miles · Jun 16, 2019
Exterior Lighting
BRAKE LIGHTS ON BOTH SIDES GETS STUCK ON ONCE THE PEDAL IS PRESSED. THIS PRODUCES NO ERROR CODES. I WAS TOLD IT COULD BE THE BRAKE PEDAL PRESSURE SENSOR SWITCH. I CHANGED THIS AND IT DID NOTHING. THIS IS VERY DANGEROUS TO OTHER DRIVERS BECAUSE THEY ARE NOT SURE IF THE CAR IS BRAKING AS THE LIGHT IS ALWAYS ON AND WILL BURN OUT TH…
Read full complaint
BRAKE LIGHTS ON BOTH SIDES GETS STUCK ON ONCE THE PEDAL IS PRESSED. THIS PRODUCES NO ERROR CODES. I WAS TOLD IT COULD BE THE BRAKE PEDAL PRESSURE SENSOR SWITCH. I CHANGED THIS AND IT DID NOTHING. THIS IS VERY DANGEROUS TO OTHER DRIVERS BECAUSE THEY ARE NOT SURE IF THE CAR IS BRAKING AS THE LIGHT IS ALWAYS ON AND WILL BURN OUT THE BULBS AND MELT THE HOUSING IF CONSTANTLY ON. THIS CAN BE REPRODUCED EITHER WHILE PARKED OR IN MOTION.
NHTSA ODI #11220395
Mileage unknown · Feb 24, 2018
EngineFuel/propulsion System
2003 BMW 325I LOW FUEL STALL
NHTSA ODI #11074692
50,000 miles · Jul 31, 2017
Electrical System
TRANSMISSION WILL DROP OUT OF GEAR AND SHUT CAR DOWN, WHILE VEHICLE IN MOTION DURING NORMAL USE. VEHICLE WILL ONLY WORK WHEN COLD, MANUFACTURER IS AWARE OF BADLY DESIGNED SMG TEMP SENSOR AND NEGLIGENTLY DESIGNED COMPUTER LOGIC THAT SHIFTS TRANSMISSION TO NEUTRAL AND SHUTS CAR DOWN.
NHTSA ODI #11011864
Mileage unknown · Nov 27, 2016
Exterior Lighting
THE ZKW XENON HEADLIGHTS HAVE A FLAW IN THE PLASTIC PROJECTOR HOUSING. THE HOUSING GETS TOO HOT AND MELTS AND THE LIGHT OUTPUT IS SEVERELY RESTRICTED. THIS HAPPENS TO 100% OF THE HEADLIGHTS MADE BY THIS MANUFACTURER AND IS A SAFETY ISSUE. THE REFLECTIVE COATING ON THE HEADLIGHTS MELTS AND THE LIGHT CAN NO LONGER BE PROJECTED O…
Read full complaint
THE ZKW XENON HEADLIGHTS HAVE A FLAW IN THE PLASTIC PROJECTOR HOUSING. THE HOUSING GETS TOO HOT AND MELTS AND THE LIGHT OUTPUT IS SEVERELY RESTRICTED. THIS HAPPENS TO 100% OF THE HEADLIGHTS MADE BY THIS MANUFACTURER AND IS A SAFETY ISSUE. THE REFLECTIVE COATING ON THE HEADLIGHTS MELTS AND THE LIGHT CAN NO LONGER BE PROJECTED OUT CORRECTLY. THE FOG LIGHTS ARE NOW BRIGHTER THEN THE HEADLIGHTS. THE VEHICLE CAN NO LONGER BE SAFELY DRIVEN AT NIGHT. SPARE PARTS ARE NOT AVAILABLE AND THE ONLY FIX IS TO REPLACE THE ENTIRE HEADLIGHTS AT A COST OF OVER $2000. THERE SHOULD BE A RECALL TO REPLACE THE HEADLIGHTS AS THIS IS A SAFETY ISSUE OF NOT BEING ABLE TO SEE.
NHTSA ODI #10928130
Mileage unknown · Oct 10, 2016
Air Bags
TAKATA RECALL. AFTER WAITING 9 MONTHS FOR REPLACEMENT OF PASSENGER SIDE AIR BAG I RECEIVED ANOTHER RECALL NOTICE FOR THE DRIVERS SIDE AIRBAG. IT HAS NOW BEEN NEARLY 15 MONTHS AND NO REMEDY IN SIGHT . RECEIVED A " FINAL REMEDY AVAILABLE " LETTER DATED SEPT. 2016 ASKING THAT I CALL DEALER FOR REPAIR. CALLED LOCAL DEALER OCTOBER 10…
Read full complaint
TAKATA RECALL. AFTER WAITING 9 MONTHS FOR REPLACEMENT OF PASSENGER SIDE AIR BAG I RECEIVED ANOTHER RECALL NOTICE FOR THE DRIVERS SIDE AIRBAG. IT HAS NOW BEEN NEARLY 15 MONTHS AND NO REMEDY IN SIGHT . RECEIVED A " FINAL REMEDY AVAILABLE " LETTER DATED SEPT. 2016 ASKING THAT I CALL DEALER FOR REPAIR. CALLED LOCAL DEALER OCTOBER 10/16 AND WAS TOLD NO PARTS ARE AVAILABLE.I HAVE NOT HAD FULL USE OF MY VEHICLE FOR NEARLY 2 YEARS AND SEE NO REMEDY COMING ANYTIME SOON.
NHTSA ODI #10915072
76,000 miles · Sep 26, 2016
Air Bags
TAKATA INFLATORS. MANUFACTURER HAS NOT PURSUED THE EXISTING RECALL IN EVEN A REMOTELY TIMELY MANNER. I WAS NOTIFIED BY LETTER DATED JULY 2015 OF THE RECALL. THAT WAS OVER 14 MONTHS AGO! I CALLED MY LOCAL BMW SERVICE CENTER WHO INFORMED ME THE REQUIRED PARTS WERE STILL NOT AVAILABLE. THE REPRESENTATIVE HERE AT SAFECAR.GOV NOT…
Read full complaint
TAKATA INFLATORS. MANUFACTURER HAS NOT PURSUED THE EXISTING RECALL IN EVEN A REMOTELY TIMELY MANNER. I WAS NOTIFIED BY LETTER DATED JULY 2015 OF THE RECALL. THAT WAS OVER 14 MONTHS AGO! I CALLED MY LOCAL BMW SERVICE CENTER WHO INFORMED ME THE REQUIRED PARTS WERE STILL NOT AVAILABLE. THE REPRESENTATIVE HERE AT SAFECAR.GOV NOTIFIED ME THAT PARTS ARE AVAILABLE. WHEN I CONTACTED MANUFACTURER "NATIONAL RECALL CALL CENTER" (800-831-1117), AS RECOMMENDED BY REP HERE AT SAFECAR, THEY SAID THEY WEREN'T FOR MY VIN. WHEN I INFORMED THEM I HAD INQUIRED HERE WITH THIS AGENCY AND WAS TOLD THE PARTS WERE AVAILABLE, THE NATIONAL CENTER SAID THEY'D CALL ME BACK IN 48 HOURS. THEY NEVER DID. DOES ANYONE TAKE THESE SAFETY RECALLS SERIOUSLY? THE MANUFACTURER CERTAINLY ISN'T.
NHTSA ODI #10909807
Mileage unknown · Aug 18, 2016
Air Bags
I SENT YOU MY FIRST COMPLAINT ON OR AROUND AUGUST 10, 2016, AND ONLY RECEIVED A 'THANK YOU' RETURN NOTE, AND THAT YOU WOULD GET BACK TO ME. YOU HAVE NOT! TO RECAPITULATE THE EARLIER COMPLAINT, I RECEIVED RECALL CAMPAIGN NO. 15V-318 IN JULY 2015, AND HAVE SINCE NOT RECEIVED ANYTHING FROM BMW. I CALLED BMW CUSTOMER RELATIONS …
Read full complaint
I SENT YOU MY FIRST COMPLAINT ON OR AROUND AUGUST 10, 2016, AND ONLY RECEIVED A 'THANK YOU' RETURN NOTE, AND THAT YOU WOULD GET BACK TO ME. YOU HAVE NOT! TO RECAPITULATE THE EARLIER COMPLAINT, I RECEIVED RECALL CAMPAIGN NO. 15V-318 IN JULY 2015, AND HAVE SINCE NOT RECEIVED ANYTHING FROM BMW. I CALLED BMW CUSTOMER RELATIONS AROUND AUGUST 4, TO FIND OUT THE STATUS OF THE AIRBAG REPLACEMENT. AFTER GETTING NO INFORMATION FROM THE FIRST CUSTOMER RELATIONS PERSON, I WAS CONNECTED TO A SUPERVISOR WHO ALSO GAVE ME NO INFORMATION. I ASKED WHEN I COULD EXPECT A AIRBAG REPLACEMENT - THEY TOLD ME 'PROBABLY BEFORE THE END OF THE YEAR'. I TOLD THEM THIS WAS AN UNACCEPTABLE, DANGEROUS SITUATION, WITH THE SUPERVISOR'S RESPONSE THAT 'NOBODY HAD DIED IN A BMW OF AN AIRBAG INCIDENT'. WHILE IT IS GOOD NOBODY HAS DIED, THE RESPONSE WAS LESS THAN ACCEPTABLE. IT IS NOW A WEEK LATER, AUGUST 18 - AND STILL NO FURTHER RESPONSE FROM BMW OR FROM THE NHTSA. YOU GUYS HAVE BEEN WORKING THIS - IS IT SAFE TO DRIVE MY CAR OR NOT? ARE YOU ASKING OR WORKING WITH BMW TO RESOLVE THIS? WHEN CAN I EXPECT A REPLACEMENT AIRBAG, OR AT LEAST A RESPONSE FROM BMW OR THE NHTSA? PLEASE GET BACK TO ME - YOUR IN-ACTION IS NOT ACCEPTABLE EITHER. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10896997
Mileage unknown · Aug 10, 2016
Air Bags
DEAR SIRS: I RECEIVED A RECALL NOTICE (15V-318) IN JULY 2015, FOR THE FRONT, DRIVER'S SIDE AIRBAG RECALL FOR MY 2003 BMW 330I. SINCE THAT TIME I HAVE NOT RECEIVED ANY ADDITIONAL CORRESPONDENCE FROM BMW OR ANYONE, TO PROVIDE STATUS. I CALLED BMWUSA, CUSTOMER SERVICE ON AUGUST 2, 2016 - I FIRST TALKED TO ANTHONY SMITH, WHO RECITE…
Read full complaint
DEAR SIRS: I RECEIVED A RECALL NOTICE (15V-318) IN JULY 2015, FOR THE FRONT, DRIVER'S SIDE AIRBAG RECALL FOR MY 2003 BMW 330I. SINCE THAT TIME I HAVE NOT RECEIVED ANY ADDITIONAL CORRESPONDENCE FROM BMW OR ANYONE, TO PROVIDE STATUS. I CALLED BMWUSA, CUSTOMER SERVICE ON AUGUST 2, 2016 - I FIRST TALKED TO ANTHONY SMITH, WHO RECITED PRESCRIBED VERBAGE, THAT I WOULD BE CONTACTED ONCE REPLACEMENT AIRBAGS WERE RECEIVED. I ASKED WHEN - HE COULD ONLY SAY 'PROBABLY BEFORE THE END OF 2016'. I TOLD HIM BMW'S HANDLING OF THIS WAS LESS THAN ACCEPTABLE, AND ASKED TO TALK TO A SUPERVISOR - I WAS CONNECTED TO A PERSON NAMED COLE, WHO REFUSED THE COURTESY OF PROVIDING A LAST NAME, ONLY HIS EXTENSION OF X8917. I ASKED COLE WHEN I COULD EXPECT TO RECEIVE A REPLACEMENT AIRBAG; HE COULD NOT ANSWER THAT. I TOLD COLE I WAS DEEPLY UPSET FOR NOT RECEIVING ANY INFORMATION (AT ALL) FROM BMW SINCE JULY 2015, AND WAS DEEPLY CONCERNED FOR MY SAFETY AND THAT OF MY PASSENGERS. HE WOULD ONLY SAY THAT 'NO ONE HAD DIED' OF AN AIRBAG INCIDENT IN A BMW - YET, AND COULD OFFER NO OTHER OPTIONS OR COMFORT FOR ME. I WROTE AN EMAIL LETTER TO BMWUSA THAT SAME DAY, DETAILING WHAT I WROTE IN THIS NOTE, RECEIVING A NOTE BACK FROM BMWUSA (CORRESPONDENCE 1-7149508707), THANKING ME FOR MY WRITING THEM, AND THAT THEY HAD FORWARDED MY EMAIL TO COLE FOR REVIEW - AND OF COURSE I HAVE NOT HEARD FROM THEM SINCE. ITS OBVIOUS THAT BMWUSA CUSTOMER RELATIONS GROUP IS LESS THAN COMPASSIONATE FOR THEIR CUSTOMERS. MY FRIENDS THAT WORK AT HONDA ARE TELLING ME TO 'GET OUT MY CAR', REGARDLESS OF WHAT BMW IS SAYING - THIS IS A DANGEROUS, UNACCEPTABLE RISK. PLEASE LET ME KNOW WHAT YOU THINK - I THINK AT THE VERY LEAST THAT BMW SHOULD PUT ME IN A SAFE CAR UNTIL THEY CAN REPLACE THIS DEFECTIVE AIRBAG. THANKS FOR YOUR TIME.
NHTSA ODI #10894875
Mileage unknown · Aug 2, 2016
Air Bags
THIS IS A CALIFORNIA CAR PARKED OUTSIDE FROM 2003-2014. FROM 2014-2016 IS HAS BEEN PARKED OUTSIDE IN NORTH CAROLINA. I WOULD THINK A 13 YEAR OLD CAR WITH THIS HISTORY WOULD BE IN THE PRIORITY A GROUP. IT IS BEEN HOT AND HUMID ITS ENTIRE LIFE. IT NEEDS TO BE REPLACED NOW. IT'S JUST A MATTER OF TIME.
NHTSA ODI #10892384
Mileage unknown · Jul 14, 2016
Child Seat
TL* THE CONTACT OWNS A 2013 BABY TREND EXPEDITION TRAVEL SYSTEM (NA), MODEL NUMBER: TJ94773. THE SEAT WAS MANUFACTURED ON MARCH 10, 2012. THE SAFETY SEAT WAS BEING UTILIZED IN A 2003 BMW 3 SERIES. AFTER BOTH REAR LATCHES WERE CONNECTED, THE REAR PASSENGER SIDE LATCH FRACTURED. THE FAILURE OCCURRED INSIDE THE VEHICLE. THE CHILD W…
Read full complaint
TL* THE CONTACT OWNS A 2013 BABY TREND EXPEDITION TRAVEL SYSTEM (NA), MODEL NUMBER: TJ94773. THE SEAT WAS MANUFACTURED ON MARCH 10, 2012. THE SAFETY SEAT WAS BEING UTILIZED IN A 2003 BMW 3 SERIES. AFTER BOTH REAR LATCHES WERE CONNECTED, THE REAR PASSENGER SIDE LATCH FRACTURED. THE FAILURE OCCURRED INSIDE THE VEHICLE. THE CHILD WAS NOT IN THE SAFETY SEAT AT THE TIME OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. ......UPDATED 07/26/16 *BF
NHTSA ODI #10884835
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA09019 · Rear Lamp Illumination
Opened Dec 18, 2009 · Closed Sep 28, 2011
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Additional source detail variants (4)
Exterior Lighting
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:brake Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:tail Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
PE09036 · Rear Lamp Illumination
Opened Aug 7, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Additional source detail variants (4)
Exterior Lighting
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:brake Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:tail Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
2003 BMW 3 Series Problems, Complaints & Recalls | Skip That Year
Illustration