2019 Audi A6

While out of town the car gave an electrical system fault with a yellow warning saying find a dealr soon. Then shortly after the warning went red and while driving all systems in the car started to shut down. Steering, transmission, throttle, dash, everything went crazy. Need to to cross 2 lanes of traffic to get off main road where there was no shoulder to pull onto a side road, very scary without power steering and the transmission putting itself into neutral. Easily could have caused an accident with my wife and 2 kids in yhe car. At that point the car was dead.

On November 8, 2022, I was driving my vehicle to the Audi Arlington dealership to service an "Electrical System Malfunction" alert that had recently appeared. Approximately one mile into my drive the car completely shut down while driving. This happened while I was proceeding through an urban intersection. All systems shut down on the car simultaneously, including every screen, hazard lights, engine and power steering, to name a few. I was able to coast to a stop while only partially exit the lane of traffic. As the car was entirely nonresponsive, it needed to be towed from that point to Audi Arlington. Audi Arlington determined that the issue resulted from a 48V generator.

Multiple warnings indicating to contact dealer (Lane departure, adaptive cruise control, collision avoidance, etc) then 1 minute later transmission failure and engine failure imminent.... pull over immediately and contact dealer. I turned into a road off main highway within a minute of the last two warnings and as I turned, my center MMI went blank then my electronic dash went blank, transmission went into neutral and the engine died all within a few seconds. Fortunately I was able to coast to a stop in the parking lot. Flatbed towed to dealer who stated most likely the generator between the lithium battery bank and gas engine failed. They have seen several in this year for A6 and A7's with mild hybrid engines. I'm lucky to be in low volume traffic as there was no power to indicate to drivers around me that my engine quit and not even turn signals worked.

I experienced a total failure of the electric system in my 2019 A6. Car stopped running in the middle of the road. Had to use the tool in the trunk to manually switch the car to neutral so I could push it off the road. Car was towed to the Audi dealer in my area. Audi dealer reported the alternator is faulty. Yellow Electrical issue warning message showed up on, dashboard, then Red electrical issue message showed indicating the vehicle will shut down. Dealer reported “a bunch” of A6s 2019 and newer are expediting these issues and parts are on back order because of it.

The contact owns a 2019 Audi A6. The contact stated that while driving at an undisclosed speed, the rearview camera and blind spot monitoring system intermittently failed to operate as needed. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the failure. The dealer reprogrammed the computer and the failure recurred. The vehicle was then taken to Sewickley Audi (526 Ohio River Blvd Suite A, Sewickley, PA 15143) where the trunk cable and an unknown module were replaced. The failure recurred and the vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 20,000.

Today, car showed electrical problem then leading to steering problem, transmission problem, all sensors shutting off, all thro flashing one by one alarms and messages on dash and then coming to a complete halt. It would not allow me to come out and locked me in. I could see that the locks were kicking in so took a micro second gap between unlock and auto lock to get out of the car forcefully. I have had situations when in traffic light, the car wouldn’t move back from neutral to drive unless I tried couple of times, but this was horrible incident. Now taking it to service to see what they are going to say, not always super helpful.

The contact owns a 2019 Audi A6. The contact received a notification from Carfax that informed him that the vehicle was included in NHTSA Campaign Number: 22V155000 (Electrical System) however, the part to do the recall repair was not yet available. The dealer had been notified of the issue and confirmed that parts were not yet available. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.

I received a yellow alert that the auto start/stop was malfunctioning. I continued to drive 8 miles until another message was displayed on the instrument panel that stated: "electrical system malfunction" with a yellow battery icon. A few seconds later the same "electrical system malfunction" with a red battery icon appeared. I then had numerous failure warnings on other car systems such as driver assistance sensors and steering; the display screens started to flash on and off. I slowly guided the car to a complete stop and called Audi Roadside Assistance for towing to my local Audi dealer.

While driving on highway, had complete electrical system failure. Received red message that said “electrical system malfunction”. Car went totally black and completely shut down within 2 minutes. I had to navigate 3 lanes to pull over with completely black cockpit after car shut down. Audi service says it’s the “starter generator”. Service said there is a chance of fire with moisture ingress in the starter generator. Apparently it’s a known issue with over 60 units on back order from their supplier Continental (no promise date available). Concerned this is a serious safety issue and will cause somebody to have a crash due to car shutting down and potential for electrical fire.