2016 Audi A6

The water pump on my 2016 Audi A6 has failed multiple times prematurely. The first water pump failed at 36,965 miles in May 2019. That repair was covered under an extended warranty I purchased. The second water pump failed around 83,000 miles in September 2025, and Audi is now quoting me $2,350 out of pocket to replace it. I am now facing a third water pump replacement, which is far earlier than expected for this type of component. These repeated failures create a significant safety concern, as sudden coolant loss can cause the engine to overheat, potentially leading to engine failure or loss of power while driving. Each problem has been diagnosed and confirmed by an authorized Audi service center. The vehicle was inspected by Audi technicians, and repairs were recommended both times. The repeated failure of this critical component strongly suggests a systemic defect with the water pump design on this model. Despite a recent Audi water pump settlement, my vehicle was excluded, even though it has now experienced two failures and is requiring a third replacement.

This vehicle had a claim for water pump replacement and the 3.0 model has a recall for the turbo charger. This vehicle is experiencing the same issues and went from 70 mph to 0 and stalled on the freeway. Thankfully the semi and other vehicles were able to avoid me or my family would be reaching out instead of me. Currently the vehicle is parked in my garage because it is unsafe to drive. Can you please advise Audi to take responsibility and offer the same recalls on the 2.0 vehicles for the water pump and turbo charger because they have the same internal parts as the 3.0 vehicles that failed and these parts were covered.

I took the vehicle into a repair shop because the check engine light is on. I was advised that the water pump is leaking and it needs to be replaced along with the thermostat. The turbo charger assembly also needs to be replaced. Both of these items appear to be deficient and were listed under recent recalls on similar Audi vehicles and this VIN was not included in either recall. However, it appears to be a similar concern and should be resolved by the Manufacturer.

I left a gas station located one mile from my house. All seemed well. I drove into my garage, shut the engine off, and saw steam coming from under the hood. Inspection showed coolant below minimum level. I had the car towed to a garage. The water pump seal and water pump had failed. The thermostat also failed. I had no warning that anything was about to happen. No warning lamps or alarms were presented. Had this happened on the freeway, the engine would have overheated and locked up before I knew that there was a problem. I would have lost control of the car. The mechanic said that this failure at such low mileage, 51, 803, was unusual. My experience is that a failed water pump should not be expected before at least 150,000 miles of use.

The contact owns a 2016 Audi A6. The contact stated that while refueling, the gas nozzle would frequently stop, causing gasoline to leak from the vehicle. The vehicle was taken to a dealer where it was discovered that the fuel tank sensor needed to be moved to another location on the vehicle. The contact was provided an estimate for the repair; however, the contact declined to seek a second opinion. The contact was assured by the dealer that the vehicle was safe to be driven. A few days after leaving the dealer, the vehicle stalled while driving at a slow speed, with the check engine warning light illuminated. Due to the failure, the vehicle was towed back to the dealer who discovered that fuel had filled up in the evaporation canister sensor which caused the fuel tank and the fuel pump to become defective. The manufacturer was notified of the failure but informed him that his vehicle was not under recall or warranty. The vehicle had yet to be repaired and remained in the possession of the dealer. The failure mileage was approximately 48,000.

The contact owns a 2016 Audi A6. The contact stated the emergency lights were illuminated. The vehicle loss coolant and overheated. The stop immediately message was displayed. The vehicle was taken to an independent mechanic who stated that the engine coolant housing assembly needed to be replaced. The vehicle was repaired. The local dealer was not contacted. The manufacturer was notified and referred the contact to NHTSA. The failure mileage was approximately 51,000.