IllustrationFAILED CT EMISSIONS TEST. CHECK ENGINE LIGHT ILLUMINATED. CONFIRMED CODE TO BE P0741. INFORMED BY AUTHORIZED TECHNICIAN THAT THE TORQUE CONVERTER REQUIRES REPLACEMENT. *TR
2003 Audi A6
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Audi A6 do not stand out strongly from the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
625–50K
850–75K
1075–100K
14100–150K
3150K+
50 reports with mileage · 16 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports5 fire reports1 injury reports
Power Train complaints
10 reportsTORQUE CONVERTER DISENGAGES AND POWER / RPM SURGE OCCURS. *TR
TRANSMISSION STARTED TO SHUDDER AND SOMETIMES THE TRANSMISSION DOES NOT GOES TO NEUTRAL WHEN THE CAR IS STOPPED, ENGINE REVS AND IT IS DIFFICULT TO STOP. PRND DISPLAY ON DASHBOARD IS BLINKING. CHECK ENGINE LIGHT IS ON. FAULT CODE SHOWS FAILURE ON TRANSMISSION CONTROL MODULE. *TR
CAR COMPLETELY STOPPED IN THE MIDDLE OF HIGHWAY AND CAR BEHIND ALMOST HIT ME. TRANSMISSION FAILED SUDDENLY. IT HAD TO BE REPLACED. RECURRING PROBLEM WITH AUDI A6 3.0 2003 CVT. *TR
CAR SHUDDERS WHEN ACCELERATING MAINLY AND ALSO SLIGHTLY FELT WHEN BRAKING-DEALER RECOMMENDS REPLACEMENT TRANSMISSION. *TR
2003 AUDI A6 HAD PROBLEMS WITH THE ENGINE LIGHT, SMOKING, AND LITTLE TO NO ACCELERATION. CONSUMER STATES THAT AFTER A FEW REPAIRS THE PROBLEM IS NOT SOLVED AND WANTS TO BE REFUNDED HER MONEY. *NJ THE DEALER INFORMED THE CONSUMER THE #1 AND #3 COIL NEEDED TO BE REPLACED. THE CONSUMER DROVE LESS THAN A MILE AND THE CHECK ENGIN…
Read full complaint
2003 AUDI A6 HAD PROBLEMS WITH THE ENGINE LIGHT, SMOKING, AND LITTLE TO NO ACCELERATION. CONSUMER STATES THAT AFTER A FEW REPAIRS THE PROBLEM IS NOT SOLVED AND WANTS TO BE REFUNDED HER MONEY. *NJ THE DEALER INFORMED THE CONSUMER THE #1 AND #3 COIL NEEDED TO BE REPLACED. THE CONSUMER DROVE LESS THAN A MILE AND THE CHECK ENGINE LIGHT CAME BACK ON BLINKING AND THE VEHICLE WAS MOVING VERY HARD. WHEN THE CONSUMER RETURNED TO THE DEALER, THEY DIAGNOSED THE VEHICLE AGAIN, THE CONSUMER WAS TOLD THE #6 IGNITION COIL NEEDED TO BE REPLACED. BECAUSE NO ONE EVER TEST DROVE THE VEHICLE WHEN IT WAS SUPPOSE TO BE FIXED THE FIRST TIME, THE DEALER REPLACED THE #6 COIL FOR FREE. THE CONSUMER LEFT THE DEALERSHIP AGAIN ONLY TO HAVE THE ENGINE LIGHT COME AGAIN, BUT IT WASN'T BLINKING. THE DEALER DIAGNOSED THE FAILURE AND STATED IT WAS THE TORQUE CONVERTER CLUTCH CIRCUIT PERFORMANCE. *JB
I HAVE HAD NUMEROUS PROBLEMS WITH MY 2003 AUDI A6 CVT TRANSMISSION. THE ENTIRE TRANSMISSION HAD BEEN REPLACED RECENTLEY, BUT THE SLIPPING OUT OF GEAR PROBLEM CONTINUES WITH NEW ONE. THE SAN DIEGO AUDI DEALERS HAVE TOLD ME THAT THEY CANNOT FIND THE PROBLEM, BUT HAVE TOLD ME TO LET THE TRANSMISSION FAIL COMPLETELY AGAIN AND THE…
Read full complaint
I HAVE HAD NUMEROUS PROBLEMS WITH MY 2003 AUDI A6 CVT TRANSMISSION. THE ENTIRE TRANSMISSION HAD BEEN REPLACED RECENTLEY, BUT THE SLIPPING OUT OF GEAR PROBLEM CONTINUES WITH NEW ONE. THE SAN DIEGO AUDI DEALERS HAVE TOLD ME THAT THEY CANNOT FIND THE PROBLEM, BUT HAVE TOLD ME TO LET THE TRANSMISSION FAIL COMPLETELY AGAIN AND THEY WILL REPLACE IT UNDER WARRANTY AGAIN. *AK
CAR SHAKES AND SHUDDERS WHEN COMING TO A STOP. WHEN TRYING TO START FROM A STOP, CAR HESITATES BEFORE MOVING. CAN ROLL BACKWARDS IF CAR IS ON AN UPHILL INCLINE. NATURAL RESPONSE IS TO DEPRESS GAS PEDAL FURTHER. TRANSMISSION THEN ENGAGES AND CAR LURCHES FORWARD. TOOK CAR TO DEALER 3 TIMES. FIRST TIME TRANSMISSION FLUID TOPPE…
Read full complaint
CAR SHAKES AND SHUDDERS WHEN COMING TO A STOP. WHEN TRYING TO START FROM A STOP, CAR HESITATES BEFORE MOVING. CAN ROLL BACKWARDS IF CAR IS ON AN UPHILL INCLINE. NATURAL RESPONSE IS TO DEPRESS GAS PEDAL FURTHER. TRANSMISSION THEN ENGAGES AND CAR LURCHES FORWARD. TOOK CAR TO DEALER 3 TIMES. FIRST TIME TRANSMISSION FLUID TOPPED OFF. SECOND TIME TRANMISSION CONTROL UNIT SOFTWARE UPGRADED. 3RD TIME WE WERE TOLD THAT THE PROBLEM CANNOT BE FIXED, EVEN WITH TRANSMISSION REPLACEMENT.*AK
FAILURE TO ACCELERATE. I EXPERIENCE MAJOR DELAYS IN ANY ACCELERATION IMMEDIATELY AFTER I HAVE DEPRESSED THE BRAKE (AT ANY SPEED) AND THEN TRY TO REACCELERATE. I UNDERSTAND THAT THIS IS A COMMON COMPLAINT AMONG ALL AUDI TIPTRONIC OWNERS REGARDLESS OF ENGINE TYPE. IT IS NOT, AS AUDI TRIES TO SAY, "TURBO LAG." IN ALMOST EV…
Read full complaint
FAILURE TO ACCELERATE. I EXPERIENCE MAJOR DELAYS IN ANY ACCELERATION IMMEDIATELY AFTER I HAVE DEPRESSED THE BRAKE (AT ANY SPEED) AND THEN TRY TO REACCELERATE. I UNDERSTAND THAT THIS IS A COMMON COMPLAINT AMONG ALL AUDI TIPTRONIC OWNERS REGARDLESS OF ENGINE TYPE. IT IS NOT, AS AUDI TRIES TO SAY, "TURBO LAG." IN ALMOST EVERY FAILURE TO DATE, I HAVE ALMOST BEEN INVOLVED IN AN ACCIDENT DUE TO THIS PROBLEM. HAD OTHER DRIVERS BEEN LESS ATTENTIVE, I MOST SURELY WOULD HAVE BEEN STRUCK. I AM HESITANT TO PULL OUT INTO ANY VOLUME OF TRAFFIC WITH THIS PERSISTENT PROBLEM. *LA
WHILE PUTTING VEHICLE IN THE REVERSE MODE IT WILL START SHAKING AND VIBRATING. *AK
Official recalls
711V267000 · Fuel System, Other:storage:tank Assembly
May 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
08V157000 · Fuel System, Gasoline:storage:tank Assembly
Apr 8, 2008
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
07V375000 · Fuel System, Gasoline:delivery:fuel Pump
Aug 28, 2007
ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 20007. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834. THIS RECALL IS A SUPPLEMENT TO A PREVIOUS CAMPAIGN (PLEASE SEE 06V017).
06V198000 · Electrical System
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
06V017000 · Fuel System, Gasoline:delivery:fuel Pump
Jan 23, 2006
ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834.
04V133000 · Electrical System
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
02V275000 · Air Bags:frontal
Oct 9, 2002
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3-SPOKE SPORT STEERING WHEELS, IT IS POSSIBLE THAT THE IGNITER FOR THE DRIVER'S SIDE AIR BAG MAY NOT HAVE BEEN PROPERLY ASSEMBLED.
Consequence & remedy
Consequence: AN IMPROPERLY POSITIONED IGNITER WILL NOT ACTIVATE THE AIR BAG IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE AIR BAGS. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.