NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
113 reports170,000 miles · Apr 10, 2014
Fuel System, Other
THERE IS NOT ACCIDENT INVOLVED YET. THERE IS A GAS SMELL ON LEFT REAR SIDE, OVER THE WHEEL ARCH ON MY AUDI A6 2001. I SEARCHED NHTSA FOR AUDI RECALL CAMPAIGN. THERE IS A RECALL CAMPAIGN# 11V267000 HOWEVER, WHEN I CONTACT AUDI-USA AT THE NUMBER PROVIDED BY THIS CAMPAIGN, THAT IS 1-800-822-2834, AFTER ASKING MY THE VEHICLE …
Read full complaint
THERE IS NOT ACCIDENT INVOLVED YET. THERE IS A GAS SMELL ON LEFT REAR SIDE, OVER THE WHEEL ARCH ON MY AUDI A6 2001. I SEARCHED NHTSA FOR AUDI RECALL CAMPAIGN. THERE IS A RECALL CAMPAIGN# 11V267000 HOWEVER, WHEN I CONTACT AUDI-USA AT THE NUMBER PROVIDED BY THIS CAMPAIGN, THAT IS 1-800-822-2834, AFTER ASKING MY THE VEHICLE MILEAGE, AUDI-USA JUST SAID MY CAR IS NOT COVERED BY THE THIS RECALL. APPARENTLY, THE DEFECT EXACTLY MATCHES WHAT THIS RECALL CAMPAIGN# 11V267000 DESCRIBES. WHY AUDI-USA REFUSES TO COVER MY CAR? I AM WONDERING WHETHER IT'S BECAUSE MY CAR IS AT HIGH MILEAGE. THEY MAY TRY TO SAVE COST, BUT THIS IS AN APPARENT SAFETY HAZARD CAUSED BY MANUFACTURING DEFECT. AND THE DEFECT SHOULD BE FIXED REGARDLESS OF VEHICLE MILEAGE. REGULATORS NEED TO OVERSIGHT THINGS LIKE THIS. THE CAR MANUFACTURERS CANNOT JUST WAIT TO FIX DEFECTS UNTIL REAL ACCIDENT HAPPENS. *TR
NHTSA ODI #10578826
97,000 miles · Mar 28, 2014
Exterior Lighting
OUR 2001 AUDI AND MANY OTHER CARS LIKE IT HAVE PLASTIC HEADLIGHTS THAT PERFORM WELL FOR SEVERAL YEARS. THEN IN ANY SUNNY LOCATION LIKE THE US SOUTHWEST THEY BEGIN TO FOG UP AND BECOME PROGRESSIVELY MORE OPAQUE. THIS RESULTS IS MORE LIGHT SCATTER USING THE HEADLAMPS AT NIGHT: THE HEADLAMPS NO LONGER FOCUS A NARROW BEAM OF LIGHT…
Read full complaint
OUR 2001 AUDI AND MANY OTHER CARS LIKE IT HAVE PLASTIC HEADLIGHTS THAT PERFORM WELL FOR SEVERAL YEARS. THEN IN ANY SUNNY LOCATION LIKE THE US SOUTHWEST THEY BEGIN TO FOG UP AND BECOME PROGRESSIVELY MORE OPAQUE. THIS RESULTS IS MORE LIGHT SCATTER USING THE HEADLAMPS AT NIGHT: THE HEADLAMPS NO LONGER FOCUS A NARROW BEAM OF LIGHT ON THE ROADWAY AHEAD. DUE TO FOGGED, OPAQUE HEAD LAMP LIGHT SCATTER VISIBILITY IS REDUCED PUTTING ESPECIALLY PEDESTRIANS AND BICYCLES AT RISK WHILE DRIVING AT NIGHT. ALSO, ONCOMING TRAFFIC EXPERIENCES GREATER NIGHTTIME GLARE FROM FOGGED HEADLAMPS INCREASING ACCIDENT RISK. OFTEN, REPLACEMENT COSTS FOR NEW PLASTIC HEADLAMPS ARE PROHIBITIVE - AT TIMES MORE THAN THE COST OF A USED CAR. MANY US DRIVERS THUS DRIVE WITH FOGGED UP, OPAQUE HEADLAMPS. PREVIOUSLY GLASS HEADLAMPS DELIVERED MANY DECADES OF RELIABLE SERVICE WITHOUT EVER FOGGING UP AS DO THE WINDOWS OF ANY OLDER CAR. I BELIEVE THE NHTSA SHOULD INVESTIGATE AND CONSIDER ISSUING A SAFETY RECALL. *TR
NHTSA ODI #10575329
89,000 miles · Feb 24, 2014
Vehicle Speed Control
TL* THE CONTACT OWNS A 2001 AUDI A6. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE ACCELERATOR PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT APPLIED THE BRAKES BUT THE VEHICLE CONTINUED TO ACCELERATE. THE VEHICLE WAS TOWED TO A MECHANIC FOR INSPECTION WHERE THEY STATED THAT THE PEDAL MODULE WAS STUCK AND NEEDED TO…
Read full complaint
TL* THE CONTACT OWNS A 2001 AUDI A6. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE ACCELERATOR PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT APPLIED THE BRAKES BUT THE VEHICLE CONTINUED TO ACCELERATE. THE VEHICLE WAS TOWED TO A MECHANIC FOR INSPECTION WHERE THEY STATED THAT THE PEDAL MODULE WAS STUCK AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000.
NHTSA ODI #10565648
149,995 miles · Dec 30, 2013
Engine
DRIVING WESTBOUND ON I20 FROM COLUMBIA, SC TO ST ROBERT/FORT LEONARD WOOD, MO WHEN ENGINE SUDDENLY LOST POWER. LIMPED ABOUT 3/4 MI TO NEXT EXIT AND CALLED FOR A TOW TRUCK. TRANSPORTED VEHICLE BACK TO NEAREST AUDI DEALER (45 MI EAST) IN COLUMBIA, SC. AUDI OF COLUMBIA DID DIAGNOSTIC AND AFTER $2527.00 DETERMINED THAT THE EXHAUST C…
Read full complaint
DRIVING WESTBOUND ON I20 FROM COLUMBIA, SC TO ST ROBERT/FORT LEONARD WOOD, MO WHEN ENGINE SUDDENLY LOST POWER. LIMPED ABOUT 3/4 MI TO NEXT EXIT AND CALLED FOR A TOW TRUCK. TRANSPORTED VEHICLE BACK TO NEAREST AUDI DEALER (45 MI EAST) IN COLUMBIA, SC. AUDI OF COLUMBIA DID DIAGNOSTIC AND AFTER $2527.00 DETERMINED THAT THE EXHAUST CAMSHAFT ON BANK 1 BROKE IN THE CENTER. THE SERVICE DEPARTMENT MANAGER STATED HE HAS NEVER SEEN OR HEARD OF THAT HAPPENING IN ALL HIS YEARS WITH AUDI. I BELIEVE THAT THIS IS A MATERIAL DEFECT AND I SHOULD NOT BE CHARGED FOR THE REPLACEMENT OF THE ENGINE (SERVICE MANAGERS RECOMMENDATION). *TR
NHTSA ODI #10557844
127,300 miles · Jun 11, 2013
Structure
I PARKED MY CAR FRIDAY NIGHT WHEN I CAME FROM WORK. I WOKE UP SATURDAY MORNING I HAD A FLOOD IN MY PASSENGER SIDE FRONT AND BACK I CHECKED ALL WINDOWS WAS SHUT SO I WENT TO MECH AND HE SAYS WITH THIS MODEL FROM 2001 TO 2004 HE SEEN THIS PROBLEM A LOT IT'S A CLOGGED DRAIN SO HE SAID ITS A DEFAULT ON AUDI. *TR
NHTSA ODI #10516204
Mileage unknown · Aug 4, 2012
Fuel/propulsion System
WHEN FILLING CAR WITH GAS THE GAS LEAKS OUT BY FILLER TUBE AT LEAST A GALLON OR MORE. HAVE TRIED TWO DIFFERENT GARAGES TO FIX PROBLEM BUT STILL LEAKS. I DON'T WANT TO HAVE AN EXPLOSION CAUSED FROM THIS PROBLEM, OR GAS LEAKED OUT MY DRIVEWAY OR ROADS. THANKS FOR YOUR HELP. I BOUGHT THIS CAR ON THE REPUTATION OF AUDI AND VW. *TR
NHTSA ODI #10469167
110,000 miles · Jul 15, 2012
Electrical System
CENTER DISPLAY LCD PANEL IN INSTRUMENT CLUSTER FADES OUT PARTICULARLY IN WARM WEATHER AND THE INFORMATION IT PROVIDES CANNOT BE READ. SINCE SOME OF THE INFORMATION SHOWN IN THIS DISPLAY IS IMPORTANT FOR SAFE OPERATION OF VEHICLE THE FAILURE OF THE DISPLAY TO BE ADEQUATELY LEGIBLE IS A SAFETY HAZARD. *TR
NHTSA ODI #10465697
100,000 miles · Jun 9, 2012
Service Brakes
WAS DRIVING IN MY 2001 AUDI A6 TO WORK, AT ABOUT 45 MPH, AND WHEN APPLY MY BRAKE, IT SUDDENLY WENT SOFT AND THE ABS LIGHT CAME ON, ALSO THE BRAKE LIGHT ON DASH STARTS FLASHING. I PERFORMED A BRAKE SERVICE BUT AND IT DID NOT CORRECT THE PROBLEM, I THEN TOOK THE VEHICLE FOR A DIAGNOSIS AND FOUND OUT IT HAD A FAULTY ABS CIRCUIT AND…
Read full complaint
WAS DRIVING IN MY 2001 AUDI A6 TO WORK, AT ABOUT 45 MPH, AND WHEN APPLY MY BRAKE, IT SUDDENLY WENT SOFT AND THE ABS LIGHT CAME ON, ALSO THE BRAKE LIGHT ON DASH STARTS FLASHING. I PERFORMED A BRAKE SERVICE BUT AND IT DID NOT CORRECT THE PROBLEM, I THEN TOOK THE VEHICLE FOR A DIAGNOSIS AND FOUND OUT IT HAD A FAULTY ABS CIRCUIT AND WOULD COST AROUND $2000 TO REPAIR. I LATER DID A RESEARCH AND LEARNED THAT THESE VEHICLES HAS A COMMON ABS PROBLEM, WHICH THE AUDI DEALERS WOULD NOT ANSWER TO. I ALSO LEARNED THIS DEVICE WERE RECALL ON THE VW. ARE THERE ANYONE TO PROTECTS US FROM THIS COSTLY, FAULTY UNIT FAILURE? *JS
NHTSA ODI #10461096
132,200 miles · Jan 24, 2012
Engine And Engine CoolingFire
THE INSULATED HEAR SHIELD AROUND THE CATALYTIC CONVERTER STARTED A SLOW BURN AND EXCESSIVE SMOKE, CAUSING A FIRE ALARM, WHILE THE CAR WAS PARKED AT MY WORK PLACE. THE FIRE COMPANY RESPONDED AND PUT THE FIRE OUT. THE INCIDENT HAPPENED A SECOND TIME. UPDATED 01/30/12 *BF
NHTSA ODI #10445388
35,000 miles · Jan 12, 2012
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2001 AUDI A6 AVANT. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE SMELLED A STRONG ODOR OF GASOLINE. THE FAILURE PROGRESSED OVER TIME AND THE CONTACT FOUND A FUEL LEAK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT FUEL WAS LEAKING FROM THE TOP OF THE FUEL TANK.…
Read full complaint
TL* THE CONTACT OWNS A 2001 AUDI A6 AVANT. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE SMELLED A STRONG ODOR OF GASOLINE. THE FAILURE PROGRESSED OVER TIME AND THE CONTACT FOUND A FUEL LEAK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT FUEL WAS LEAKING FROM THE TOP OF THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 35,000. UPDATED 02/01/12 *BF UPDATED 02/07/12*BF THE CONSUMER STATED AUDI AGREED TO PAY THE COST OF REPLACING THE FUEL TANK. UPDATED 02/22/12
NHTSA ODI #10443555
Official recalls
7May 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Apr 8, 2008
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Apr 7, 2003
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.7L ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE CALCULATED "VEHICLE NORMAL LOAD" EXCEEDS THE ALLOWABLE WEIGHT OF THE AXLE LOAD WITH TIRE DIMENSION 225/45R 17 91Y BY 19KG.
Consequence & remedy
Consequence: Not supplied
Remedy: DEALERS WILL REPLACE ALL FIVE TIRES. OWNER NOTIFICATION BEGAN ON SEPTEMBER 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-800-822-2834.
Jun 18, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES (ALLROAD). WHEN ACTIVATING THE WINDSHIELD WIPER UNDER HEAVY LOAD CONDITIONS SUCH AS FREEZING, SNOW OR HEAVY RAIN, ONE WIPER COULD BE DELAYED BEHIND THE OTHER WIPER.
Consequence & remedy
Consequence: IF THAT HAPPENS, THE WIPER BLADES, BECAUSE THEY OVERLAP WIPING AREAS, COULD BECOME ENTANGLED WITH EACH OTHER AND CEASE FUNCTIONING. THIS COULD IMPAIR THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL REPLACE THE ENTIRE DRIVER SIDE WIPER ARM. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
May 3, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Consequence & remedy
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
PE02008 · Brake And Clutch Pedal Bracket
Opened Jan 23, 2002 · Closed Jul 12, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration