2013 Audi A5

Turned AC on blew out cool air all of sudden the air went out hot air blowing, smelt burning and saw smoke on passenger side (not a lot,but enough to raise concerns) turned AC shut climate off, turned car off tried it again no air just heat blowing. brother in law put it on machine , gave a sensor code, replaced sensor put a can of air in, still blowing out hot air. and if ran too long it will smoke and burning scent.

The contact owns a 2013 Audi A5. The contact stated that after activating the AC system, there was hot air and a burning odor coming from the passenger’s side vents. The contact associated the failure with NHTSA Campaign Number: 17V002000 (Engine and Engine Cooling). The contact called an independent mechanic and referenced the recall campaign. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the VIN was not under recall. The failure mileage was approximately 157,653.

I was having an issue with my 2013 Audi A5 starting. A call to roadside assistance was able to jump my battery and the car would start and run. However, the same issue kept happening. The EPC warning light would come on and it took a few weeks to get scheduled with a mechanic. I purchased a mobile jump starter myself because I never knew when the car would or wouldn't start. After taking the car to Audi, they found the "transmission coolant valve failing internally causing coolant to migrate up connector - this is causing a short which is draining the battery. If not fixed it will continue to deplete the batter. Recommend replacing valve and and connector". [2023 Audi Inspection Report.pdf] This was verified by another mechanic who did the work and shared the faulty, corroded transmission pump connector and leaking valve. [photo: 2023 Corroded connector Transmission Coolant Valve.jpg; 2023 Transmission Coolant Valuve and connector.jpg] I won't speculate about the potential outcomes of such a failure, but I was told by my mechanic before I brought it in that I should no longer jump the car, because if what Audi found was correct, I could at minimum cause a full failure of the car's electrical system or a fire could start and recommended that I tow the car in for repair, which is what I did. An internet search shows this isn't a unique or isolated issue. Audi owners over the past 7+ years have been experiencing the same issue with the transmission coolant seeping into electrical components, causing shorts and electrical problems like mine. [XXX] [XXX] [XXX] This pump and its proximity to electrical components is a dangerous risk to drivers not aware that what appears as a simple dead battery, could in fact be one jump start away from disaster. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have experienced several failures and 3 recalls with my vehicle since I purchased it brand new. I have paid out thousands of dollars over the years for repairs that I feel were faulty being that I am on the only owner of the vehicle. I have approximately a little under 75k miles on my vehicle although I purchased in 2012 (2013 vehicle) only to take it to dealerships and pay for this and that but most recently my major complaint is my car has stopped on me 4 times and I paid originally for what the dealership stated was the problem only to take it back 3 times and now they state the FUEL PUMP is the problem and there is no recalls. Audi is known to have recalls on FUEL PUMPs but at this time do not reflect on my vehicle. However, my car has not been in an accident, I am the only owner, the mileage is under 100k and there is no explanation as to why the fuel pump needs replacing. Please look into this. Thank you.

The contact's cousin owns a 2013 Audi A5. The contact stated while driving at an undisclosed speed, the vehicle began to overheat. The warning message "Pull Over and Check Coolant" was displayed. The contact veered to the side of the road and upon checking the coolant reservoir, the contact noticed that the coolant was leaking. The contact added coolant and was able to continue driving. However, the failure reoccurred increasingly. The contact stated that the coolant would leak onto the ground while refilling the coolant reservoir. The contact stated that the vehicle was no longer drivable. The contact became aware that the VIN was included in NHTSA Campaign Number: 18V229000 (Engine and Engine Cooling). The vehicle was taken to the dealer for the recall repair. However, as the contact's friend was picking up the vehicle on his behalf, he noticed that there was no coolant in the vehicle. The dealer then added coolant however, the failure recurred while driving. The dealer was notified and advised the contact that the failure was not associated with the recall. The vehicle was then taken to an independent mechanic where the coolant pump sensor was replaced; however, the failure recurred a month later. The manufacturer was notified of the failure and informed the contact that they could not assist as the dealer had already marked the recall as completed. Additionally, the contact stated that the interior lights of the vehicle would fail to operate intermittently. The vehicle was not repaired. The failure mileage was approximately 83,000.

LOSS OF POWER WHILE DRIVING. I WAS DRIVING AND THE CAR LOST POWER AND STARTED SHUDDERING, EPC WARNING LIGHT CAME ON AND IT SEEMED LIKE IT MIGHT STALL. SINCE I WAS DRIVING I PUSHED IN THE CLUTCH AND COASTED TO A STOP. I SHUT IT OFF AND RESTARTED IT AND IT WORKED NORMALLY SO I DROVE HOME. I DROVE IT THE NEXT DAY AND HAD NO PROBLEMS. ON A FOLLOWING DAY IT DID THE SAME THING, LOSS OF POWER, SHAKING, NOT WORKING RIGHT. SOMETIMES IT SEEMED JUST FINE OTHER TIMES IT HAD PROBLEMS. I TOOK IT TO A SHOP TO HAVE DIAGNOSIS AND THEY DISCOVERED WATER IN THE ENGINE COMPUTER CONNECTOR AND TRACED IT TO A COOLING VALVE LEAK THAT ALLOWS WATER IN THE CONNECTOR AT THE VALVE TO ENTER THE 2 WIRE CONNECTOR AND APPARENTLY THE WATER WICKS UP THE CONTROL WIRE TO THE COMPUTER CONNECTOR AND SHORTS OUT CONNECTIONS TO COILS AND OTHER ENGINE ELECTRONICS. I SEARCHED THE WEB FOR INFORMATION AND DISCOVERED THAT THIS IS THE SAME ISSUE THAT HAS AFFECTED 2010 - 2013 AUDI A8 AND THE CAR WAS RECALLED. SEE 16V619000. I'M WONDERING WHY MY 2013 A5 THAT HAD THE EXACT SAME PROBLEM WAS NOT RECALLED. I HAVE PICTURE OF THE ENGINE COMPUTER SHOWING WATER THAT WAS IN THE CONNECTOR AND PIN 35 IS GREEN. THE 2 WIRE CONNECTOR WAS REMOVED FROM THE VALVE AND HAS ISSUES, IT IS CONNECTED TO PIN 35 OF THE ECM

MY A5 COUPE WAS AFFECTED RECALL 17V622. I BOOKED AN APPOINTMENT MONTHS AGO WITH SILVER SPRING AUDI. THAT APPOINTMENT WAS CANCELLED DUE TO THE DEALERSHIP NOT HAVING THE PARTS TO ADDRESS THE RECALL. I'VE CALLED MULTIPLE TIMES TO TRY TO RESCHEDULE BUT THE PARTS REMAIN UNAVAILABLE. THE DEALERSHIP, TODAY, TRIED TO DISCOURAGE ME FROM BEING ADDED TO A WAIT LIST FOR THE PART GIVEN THAT OVER 100 PEOPLE WERE ALREADY ON THE LIST. (THAT DISCOURAGEMENT MADE NO SENSE TO ME. IT SEEMS LIKE EVERYONE AFFECTED BY THE RECALL WHO USES THAT DEALERSHIP SHOULD BE ON THE WAITING LIST WITHOUT EVEN HAVING TO CALL IN.)