IllustrationMechatronics unit failed, stalled on freeway nearly caused an accident behind me.
2016 Audi A3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2016 Audi A3 do not stand out strongly from the model-year median of 26.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all A3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 17 of 81 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports2 fire reports1 injury reports
Power Train complaints
6 reportsThe **mechatronic unit** (integrated into the S-Tronic dual-clutch transmission) is the primary component that fails. This unit controls gear shifts, clutch engagement, and hydraulic pressure within the transmission. Common failure points include: - Internal electronic control module (ECU) faults. - Malfunctioning solenoids …
Read full complaint
The **mechatronic unit** (integrated into the S-Tronic dual-clutch transmission) is the primary component that fails. This unit controls gear shifts, clutch engagement, and hydraulic pressure within the transmission. Common failure points include: - Internal electronic control module (ECU) faults. - Malfunctioning solenoids or pressure valves. - Software glitches or calibration errors. **2. Safety Risks** Mechatronic failure poses significant safety risks: - **Erratic Gear Shifts**: Sudden jerks, delayed engagement, or refusal to shift gears could lead to loss of vehicle control, especially in traffic or during overtaking . - **Limp Mode**: The transmission may default to a single gear (e.g., 3rd gear), severely limiting acceleration and braking responsiveness . - **Complete Gear Loss**: Loss of reverse or multiple forward gears increases collision risks during parking or low-speed maneuvers . --- **3. Confirmation by Dealers/Service Centers** Dealers and independent specialists can reproduce and confirm the issue through: - **Diagnostic Scans**: Fault codes like "implausible gear ratio," "valve electrical faults," or "clutch adaptation limits" often indicate mechatronic failure . - **Physical Testing**: Symptoms such as harsh shifting, RPM fluctuations, or transmission warnings (e.g., flashing PRNDS lights) are observable during test drives . - Audi has issued **Technical Service Bulletins (TSBs)** for related transmission issues, though the 2016 A3 e-tron’s mechatronic unit isn’t part of a formal recall.
What component or system failed or malfunctioned, and is it available for inspection upon request? Power Train system failed also engine light is now on How was your safety or the safety of others put at risk? Me and my toddler were in the vehicle when it started to jerk in bad traffic. Has the problem been reproduced or confir…
Read full complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? Power Train system failed also engine light is now on How was your safety or the safety of others put at risk? Me and my toddler were in the vehicle when it started to jerk in bad traffic. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the mechanic said this is a serious problem and i should be concerned. He stated i should not drive my vehicle. It was inspected by a certified mechanic. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, everything happen at one time.
I was entering the interstate and accelerating to merge with the traffic. When I reached about 70 mph the car stalled and a message appeared, transmission faulty, no reverse, safe to continue to drive. The car was drivable at a low speed and a high rpm. After having it towed to an Audi dealership, I was informed that the transmi…
Read full complaint
I was entering the interstate and accelerating to merge with the traffic. When I reached about 70 mph the car stalled and a message appeared, transmission faulty, no reverse, safe to continue to drive. The car was drivable at a low speed and a high rpm. After having it towed to an Audi dealership, I was informed that the transmission would need to be replaced. According to the dealership, the mechatronic unit was faulty due to an unknown short in the transmission.
Gearshifter sensor going off. Been told this shifter issue can cause car to shift into a different gear at any given moment. Read plenty of forums reporting the same thing.
Fault codes: P072C00, P072B00, P174A00, P072600, P179D00, P173400. Name of codes in order above, Stuck in Gear 1, Stuck in Reverse, Valve 3 in partial transmission 1, Engine Speed Inp.Circ., Cooling oil valve, Starter release from the selector level sensor system.
Official recalls
324V110000 · Fuel System, Gasoline
Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
22V543000 · Air Bags:frontal:passenger Side:inflator Module
Jul 27, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2016 Audi TT Roadster, TT Coupe, S3 Sedan, R8 Coupe, A3 Sedan, A3 Etron, A3 Cabriolet, 2016 Golf Sportwagen, Golf R, Golf GTI, Golf A7, and E Golf vehicles. During air bag deployment, the front passenger air bag may explode or deploy improperly.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking occupants, resulting in serious injury or death. An improper air bag deployment may not properly restrain the occupant, increasing their risk of injury in a crash.
Remedy: Dealers will replace the front-passenger air bag module, free of charge. Owner notification letters were mailed December 16, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298. Audi's customer service at 1-800-253-2834. Volkswagen's number for this recall is 69DY and 61C1.
21V198000 · Air BAGS:ON-OFF Switch Assembly; Air Bags:sensor:occupant Classification:front Passenger
Mar 22, 2021
Volkswagen Group of America, Inc. (Audi) is recalling certain 2015-2020 Audi S3 Sedan, A3 Sedan, 2016-2018 A3 Etron, 2017-2020 RS3 Sedan, and 2015-2019 A3 Cabriolet vehicles. The passenger occupant detection system (PODS) may malfunction and switch off the passenger air bag even when the seat is occupied.
Consequence & remedy
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and update the PODS control module, free of charge. Owners letters were mailed December 23, 2021. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 69BY.
Additional source detail variants (2)
Air Bags:sensor:occupant Classification:front Passenger
Volkswagen Group of America, Inc. (Audi) is recalling certain 2015-2020 Audi S3 Sedan, A3 Sedan, 2016-2018 A3 Etron, 2017-2020 RS3 Sedan, and 2015-2019 A3 Cabriolet vehicles. The passenger occupant detection system (PODS) may malfunction and switch off the passenger air bag even when the seat is occupied.
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and update the PODS control module, free of charge. Owners letters were mailed December 23, 2021. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 69BY.
Air BAGS:ON-OFF Switch Assembly
Volkswagen Group of America, Inc. (Audi) is recalling certain 2015-2020 Audi S3 Sedan, A3 Sedan, 2016-2018 A3 Etron, 2017-2020 RS3 Sedan, and 2015-2019 A3 Cabriolet vehicles. The passenger occupant detection system (PODS) may malfunction and switch off the passenger air bag even when the seat is occupied.
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and update the PODS control module, free of charge. Owners letters were mailed December 23, 2021. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 69BY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.