SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2016 Aprilia Caponord Rally

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
1Owner complaints

Model-year median: 1

1Recall campaigns

View recall details →

0Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
1
2016
Compare all Caponord Rally years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Electrical System
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 1 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Electrical System complaints

1 reports
Clear category filter
2,000 miles · Oct 23, 2017
Electrical System

THE BIKE WAS ON THE HIGHWAY IN 4TH GEAR TRAVELING AT ABOUT 60MPH AND THE ENGINE CUT OUT. THERE WERE NO WARNING LIGHTS THAT APPEARED ON THE DASH OR ANY OTHER APPARENT INDICATION OF A FAULT ON THE BIKE. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD BUT THE ENGINE WOULD NOT RESTART. I THEN EXERCISED ALL OF THE SWITCHES: THE TURN SIGN…

Read full complaint

THE BIKE WAS ON THE HIGHWAY IN 4TH GEAR TRAVELING AT ABOUT 60MPH AND THE ENGINE CUT OUT. THERE WERE NO WARNING LIGHTS THAT APPEARED ON THE DASH OR ANY OTHER APPARENT INDICATION OF A FAULT ON THE BIKE. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD BUT THE ENGINE WOULD NOT RESTART. I THEN EXERCISED ALL OF THE SWITCHES: THE TURN SIGNAL, THE HIGH BEAM, THE SIDE STAND, THE CLUTCH, BOTH BREAK PEDALS, THE LED LIGHT SWITCH, THE CRUISE CONTROL, AND THE HEATED GRIPS BUT THE BIKE WOULD STILL NOT RESTART. I TURNED THE IGNITION OFF FOR 2-3 MINUTES AND WAS ABLE TO TURN IT BACK ON AND GET THE BIKE RESTARTED. I DROVE FOR ANOTHER MILE AND THE SAME ISSUE HAPPENED AGAIN BUT I WAS NOT ABLE TO GET THE BIKE RESTARTED. I CHECKED THE CONNECTIONS THAT I HAD ACCESS TO: FUSES, HAND CONTROLS, TIP OVER SENSOR AND THEY ALL SEEMED TO BE FULLY SEATED. AFTER ABOUT 15 MINUTES, THE BIKE STARTED AGAIN WITH NO REASONABLE INFORMATION AS TO WHAT COULD HAVE BEEN THE REASON.

NHTSA ODI #11035920

Official recalls

1

16V691000 · Service Brakes, Hydraulic:foundation Components:master Cylinder

Sep 26, 2016

Piaggio Group Americas, Inc. (Piaggio) is recalling certain model year 2014-2015 Aprilia Tuono V4 1000, 2016 Tuono V4 1100, 2015 Caponord 1200 ABS/ADD, and 2016 Caponord Rally motorcycles manufactured June 18, 2013, to June 13, 2016. The affected motorcycles have a front brake master cylinder that may allow air into the hydraulic circuit, causing a longer than expected braking distance.

Consequence & remedy

Consequence: If an abnormal distance is required to stop the motorcycle, there is an increased risk of a crash.

Remedy: Aprilia will notify owners, and dealers will replace the front brake master cylinder pushrod and boot assembly, free of charge. The recall began October 04, 2016. Owners may contact Aprilia customer service at 1-866-705-1727.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.