NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
341 reportsMileage unknown · Jun 16, 2025
Engine
Connecting rod bearing seizure leading to engine failure on the TLX 2018 engine 3.5 liter V6 engine. Our 2015 TLX Acura we had to replace our engine because of the connecting rod bearing seizure and our extended warranty covered it around 2020. In 2023 the second the Acura motor which is TLX 2018 engine 3.5 liter V6 failed due t…
Read full complaint
Connecting rod bearing seizure leading to engine failure on the TLX 2018 engine 3.5 liter V6 engine. Our 2015 TLX Acura we had to replace our engine because of the connecting rod bearing seizure and our extended warranty covered it around 2020. In 2023 the second the Acura motor which is TLX 2018 engine 3.5 liter V6 failed due to same problem, connecting rod bearing seizure. Acura will not do a recall on that motor. They say because its was manufacture in a different warehouse its not covered or a problem. I know there are other people struggling with the same issues on the 2018 engine. I know there are other investigations on this motor.
NHTSA ODI #11667183
Mileage unknown · May 29, 2025
Back Over PreventionEngineVehicle Speed Control
EVERYTHING PREVIOUSLY REPORTED ( ON OTHER INCIDENTS REPORTS) HAPPENED WHILE MY DAUGHTER WAS DRIVING ON THE HIGHWAY! YOU NEED TO CORRECT THIS!!! [XXX] NHTSA ID NUMBER: 11641522 Components: ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL NHTSA ID Number: 11641522 Incident Date [XXX] Consumer Location TEMPE, AZ Vehi…
Read full complaint
EVERYTHING PREVIOUSLY REPORTED ( ON OTHER INCIDENTS REPORTS) HAPPENED WHILE MY DAUGHTER WAS DRIVING ON THE HIGHWAY! YOU NEED TO CORRECT THIS!!! [XXX] NHTSA ID NUMBER: 11641522 Components: ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL NHTSA ID Number: 11641522 Incident Date [XXX] Consumer Location TEMPE, AZ Vehicle Identification Number [XXX] *** Summary of Complaint CRASHNo FIRENo INJURIES0 DEATHS0 I was driving on the freeway going at the speed of traffic about 65-70mph then suddenly I heard my car engine slowing down and multiple lights popped up on my dashboard. I looked at my speedometer and it indeed was decreasing in speed. I tried to accelerate little by little and it did not. My check brake system, check brake hold system, check power steering system, check VSA system, check hillstart assist system, check emission system lights popped up on my dashboard. My car felt like I was popping the clutch, jerking a lot. I was able to move over to the right shoulder and park. I turned the car off and I was able to turn it back on unfortunately but the lights were still popping up and my car kept jerking and not accelerating. This happened while driving on the highway this is extremely dangerous! There has been others with the same issue. 1 Affected Product Copy Link to Information July 12, 2024 NHTSA ID NUMBER: 11601499 Components: POWER TRAIN, VEHICLE SPEED CONTROL NHTSA ID Number: 11601499 Incident Date [XXX] Consumer Location HUNTINGTON BEACH, CA Vehicle Identification Number [XXX] Summary of Complaint CRASHNo FIRENo INJURIES0 DEATHS0 While driving on the freeway/highway my vehicle went into limp mode and shifted into neutral. My vehicle would not allow me to shift gears and the car would not let me accelerate anymore. I had to think quickly and move out from upcoming traffic. With little speed I had on my vehicle I could only shut down the car and wait for a tow truck. T INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11663635
Mileage unknown · May 10, 2025
Power Train
Hi, I have had a couple instances where the engine revved up between gears. Both times, I remember it happening rather soon after starting off from a stop sign. I didn't pay it much mind, but noted it. Just today, I asked my wife ([XXX]) whether she had noticed anything with the car. I purposely didn't ask any leading quest…
Read full complaint
Hi, I have had a couple instances where the engine revved up between gears. Both times, I remember it happening rather soon after starting off from a stop sign. I didn't pay it much mind, but noted it. Just today, I asked my wife ([XXX]) whether she had noticed anything with the car. I purposely didn't ask any leading questions. She said a few times it would jump instead of smoothly going to the next gear. In Seaside, OR, I started to pull out onto [XXX], planning to take a right and head south bound. There was a Southbound car approaching from the North, but I had plenty of time to pull out and get up to speed. Immediately after starting out, the car popped into neutral and the RPMs raced. I already had some momentum and was on the highway, so I couldn't brake, and because it went into neutral, I hadn't finalized my turn so I was still pointing SE. As the car quickly approached, all I could do was use what little momentum I had and continue into the Northbound lane so the oncoming car could pass. Because of the slight slope to the Northbound shoulder, I was able to slowly come to a stop. I put the car in Park, turned it off, then back on, and everything came back to normal. I cannot begin to express how scared I was. I have lost brakes before in a car, but I know to use the emergency brake. I was completely dumbfounded as to how to react. Had there been oncoming traffic, it would have been an awful accident. Why is there no recall on this? I researched on Google and found a recall on 2015 Acura TLX 6-cylinder transmission due to a bad wiring harness on their 9-Speed transmission. I know mine is an 8-speed, but would it not use the same wiring harness with slight modifications? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11660119
Mileage unknown · Apr 30, 2025
Electrical SystemService Brakes
Electrical brake signal came on and emission light
NHTSA ODI #11657951
Mileage unknown · Apr 12, 2025
EngineLane Departure
Oil pump seal leaking, was leaking prior to rod bearing recall repair, Acura didn't recommend nor replace during recall, engine is smoking, also at night, lane keep assist repeatly steers towards passing vehicle headlights almost causing head-on collision, extremely scary, this is ridiculous and I'm stuck with vehicle being I'…
Read full complaint
Oil pump seal leaking, was leaking prior to rod bearing recall repair, Acura didn't recommend nor replace during recall, engine is smoking, also at night, lane keep assist repeatly steers towards passing vehicle headlights almost causing head-on collision, extremely scary, this is ridiculous and I'm stuck with vehicle being I'm upside down on loan, Absolutely a nightmare!!!! Contacted dealership that completed recall and was given run around so I called acura and they spoke with dealer, dealer waived diagnostic fee, but are charging for parts n services which I can't afford. And, I no longer trust them under my hood so unsure of what to do!!! This is my hard earned money at work!!!
NHTSA ODI #11654261
Mileage unknown · Mar 30, 2025
Electrical SystemEngineFuel/propulsion System
acura tlx stop start system It will turn off on red light or stop! Engine fails to restart on its own! Jump start required!!!! Is NOT SAFE for millions of families!
NHTSA ODI #11651577
60,000 miles · Mar 17, 2025
Engine And Engine CoolingPower Train
The contact owns a 2015 Acura TLX. The contact stated while driving approximately 45 MPH, the vehicle failed to maintain the speed while the accelerator pedal was depressed. The contact stated that the vehicle lost automotive power. Several unknown warning lights were illuminated. The contact sustained injuries upon pre-existing…
Read full complaint
The contact owns a 2015 Acura TLX. The contact stated while driving approximately 45 MPH, the vehicle failed to maintain the speed while the accelerator pedal was depressed. The contact stated that the vehicle lost automotive power. Several unknown warning lights were illuminated. The contact sustained injuries upon pre-existing injuries from the failure and sought medical attention. The contact was able to pull onto the shoulder of the roadway. The vehicle was towed to a local dealer where it was diagnosed that the cluster had caused the catalytic converter to fail. The vehicle was repaired at the owner's expense. The contact stated that the vehicle failed to respond as needed while the accelerator pedal was depressed. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); however, there was an abnormal sound coming from the transmission. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.
NHTSA ODI #11648801
Mileage unknown · Mar 14, 2025
Back Over PreventionElectrical System
I will be driving down the interstate and the car will go into neutral and throw a transmission code. It appears to happened when the car reaches 60mph.
NHTSA ODI #11648376
Mileage unknown · Feb 10, 2025
Forward Collision AvoidanceUnknown Or Other
Car was parked with Emergency Brake Parking on. Returned a few minutes later and couldn’t move the car. Mulitple errors popped on the dash board and the Navi screen. Reset the EBP and even disconnected the battery to try and rest it but nothing happened. Although still starts, my car won’t still move and I had to get it towed t…
Read full complaint
Car was parked with Emergency Brake Parking on. Returned a few minutes later and couldn’t move the car. Mulitple errors popped on the dash board and the Navi screen. Reset the EBP and even disconnected the battery to try and rest it but nothing happened. Although still starts, my car won’t still move and I had to get it towed to the repair shop.
NHTSA ODI #11641849
Mileage unknown · Feb 10, 2025
Electrical SystemUnknown Or Other
All lights turned on randomly during drive. Replaced battery 2x seeing it was a common issue in my year acura and also newer models. Still have the issue occuring. All lights from transmission error to lane keep asist ect.
NHTSA ODI #11641621
Official recalls
6Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Jan 29, 2019
Honda (American Honda Motor Co.) is recalling certain 2016-2018 Acura MDX, 2015-2019 Acura TLX and 2015-2017 Honda Accord vehicles, equipped with a 3.5L V6 engine. Particulates in fuel may adhere to the internal components of the fuel pump, reducing its performance.
Consequence & remedy
Consequence: Reduced fuel pump performance can result in an engine stall, increasing the risk of crash.
Remedy: Honda will notify owners, and dealers will update the fuel injection engine control unit (FI-ECU) software and, if necessary, replace the fuel pump, free of charge. The recall began March 25, 2019. Owners may contact customer service at 1-888-234-2138. Acura's recall number for this recall is P3W. Honda's recall number for this recall is N3X.
Sep 6, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura TLX 2WD and 4WD vehicles. In the affected vehicles, the transmission wire harness connections may have insufficient crimps, and, as a result, the transmission may unexpectedly shift to neutral.
Consequence & remedy
Consequence: If the vehicle unexpectedly shifts to neutral, there is an increased risk of a crash.
Remedy: Acura has notified owners, and dealers will, based on the automatic transmission serial number, update the transmission software to prevent the transmission from shifting into neutral due to a faulty crimp, free of charge. The recall began January 13, 2017. Owners may contact Acura Client Relations at 1-888-234-2138. Honda's number for this recall is KC2.
Dec 8, 2014
American Honda Motor Co. (Honda) is recalling certain model year 2015 Acura TLX V6 2WD vehicles manufactured July 14, 2014, to November 12, 2014, and certain 2015 TLX V6 SH-AWD vehicles manufactured August 26, 2014, to November 10, 2014. The automatic transmission parking pawl may become contaminated or the park rod may become dislodged or broken. This may prevent the transmission from shifting into the Park position.
Consequence & remedy
Consequence: If the shift indicator displays "Park" but the park lock does not engage, the vehicle may roll away increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will inspect and replace the transmission if necessary, free of charge. The recall began January 30, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JM8.
Oct 1, 2014
American Honda Motor Co. (Honda) is recalling certain model year 2015 Acura TLX AWD vehicles manufactured August 26, 2014, to September 20, 2014. The affected vehicles may have incorrect values for the Gross Vehicle Weight Rating (GVWR) and Gross Axle Weight Rating (GAWR) front and rear printed on the safety certification label. As such, the vehicles do not conform to Part 567, "Certification."
Consequence & remedy
Consequence: If the vehicle is loaded to the specifications listed on the label, tire failure may result, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will install a corrected certification label, free of charge. The recall is expected to begin on October 21, 2014. Owners may contact Honda customer service at 1-800-382-2238. Honda's number for this recall is JK6.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.