NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
82 reportsClear category filterMileage unknown · Oct 8, 2024
Engine
Issue with Auto Idle Stop. I have had multiple instances of the auto idle stop kicking in and shutting the car off while I am at a stoplight. This has resulted in VERY close calls with me getting rear ended. I have taken the vehicle in to be inspected at an Acura dealership only to be told that they cannot replicate the issue. W…
Read full complaint
Issue with Auto Idle Stop. I have had multiple instances of the auto idle stop kicking in and shutting the car off while I am at a stoplight. This has resulted in VERY close calls with me getting rear ended. I have taken the vehicle in to be inspected at an Acura dealership only to be told that they cannot replicate the issue. When this issue occurs, it takes about a minute to get the car working again. The dashboard lights up with a lot of different flashing lights. There was no warning prior to this issue occurring. You cannot permanently shut off the auto idle stop and I should not be expected to remember to do it every time I get into the vehicle. I am afraid that one day this will cause a bad car accident that will lead to myself or my family getting severely injured/killed as other drivers are not aware that the car won't be going. The most recent incident occurred last weekend.
NHTSA ODI #11618765
54,000 miles · Oct 1, 2024
Engine
The contact owns a 2020 Acura MDX. The contact stated while driving 65 MPH and attempting to stop, the brake pedal was depressed; however, the vehicle failed to respond, and the engine shut off unintendedly. The “Idle Stop” message was displayed on the instrument panel. The vehicle was not taken to be diagnosed or repaired. The …
Read full complaint
The contact owns a 2020 Acura MDX. The contact stated while driving 65 MPH and attempting to stop, the brake pedal was depressed; however, the vehicle failed to respond, and the engine shut off unintendedly. The “Idle Stop” message was displayed on the instrument panel. The vehicle was not taken to be diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 54,000.
NHTSA ODI #11617600
Mileage unknown · Aug 26, 2024
EngineFuel/propulsion SystemUnknown Or Other
Auto Idle Mode - After we've stopped and released the brake to go forward, the car will then shift to neutral by itself instead of restarting to drive. This has happened frequently and is now starting to happen more often. This is a safety issue, especially if you're the last car in line and other cars are traveling 55-60 miles…
Read full complaint
Auto Idle Mode - After we've stopped and released the brake to go forward, the car will then shift to neutral by itself instead of restarting to drive. This has happened frequently and is now starting to happen more often. This is a safety issue, especially if you're the last car in line and other cars are traveling 55-60 miles behind you on a major road and see a green light ahead. Each time this happens, we have to turn off the car and try to restart the car, and sometimes this has been iffy and we've had to repeat the process a couple of times. There were no warning lights of problems with any of car components. There have been similar reports of this occurring: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11610864
Mileage unknown · Aug 11, 2024
Engine
The auto idle engine stop malfuctions routinely shutting the engine off completely and requiring the driver to engage PARK, hit STOP, and RESTART engine before engaging DRIVE to proceed. We have experienced several near miss accidents or potentially caused accidents because drivers behind you have no idea what is going on. Thi…
Read full complaint
The auto idle engine stop malfuctions routinely shutting the engine off completely and requiring the driver to engage PARK, hit STOP, and RESTART engine before engaging DRIVE to proceed. We have experienced several near miss accidents or potentially caused accidents because drivers behind you have no idea what is going on. This issue is not just at stop lights but also interstate driving where traffic comes to a complete stop. I requested my Acura dealer permanantly disable this feature- they declined - I believe because it is an "Emission" feature that has gone wrong. I have seen "hack" options on line to disable this feature but fear for my safety - either way.
NHTSA ODI #11607779
Mileage unknown · Jul 31, 2024
Engine
My MDX will randomly shut itself off while at a red light. It takes MULTIPLE attempts to get it restarted. The vehicle is available for inspection upon request. My safety and the safety of others was put at risk and continues to be at risk! This has happened at a highway red light multiple times. I am impeding the flow of traffi…
Read full complaint
My MDX will randomly shut itself off while at a red light. It takes MULTIPLE attempts to get it restarted. The vehicle is available for inspection upon request. My safety and the safety of others was put at risk and continues to be at risk! This has happened at a highway red light multiple times. I am impeding the flow of traffic at an intersection with EIGHT lanes and FOUR lanes cross traffic. People move through this intersection extremely fast. This puts me at risk of causing an accident, injury the occupants of my vehicle and the occupants of the other involved vehicles. There is no warning as to when this will occur and there are no warnings at the time of the actual event either. I called the dealership and the service department acknowledged there have been others with the same issue. Acura is aware of the issue yet there is NO RECALL?? There is a Service Bulletin issued January 2023 by Acura admitting to the issue and it shows how Acura will resolve the issue for affected vehicles. If Acura is aware of the issue and the dangers of it, why have they not issued a recall to rectify the situation? The vehicle has not been inspected by the manufacturer, police, insurance representatives or others. I have a service appointment with the local dealership. There are no warning lamps, messages or other symptoms prior to the failure. The first occurrence was about four months ago. The second occurred three months ago. It occurred again today. THIS IS AN ACCIDENT AND LAWSUIT WAITING TO HAPPEN. SOMEONE COULD BE SERIOUSLY INJURED OR KILLED DUE TO ACURA’S NEGLIGENCE!!!
NHTSA ODI #11605689
Mileage unknown · Jul 29, 2024
EngineUnknown Or Other
WHEN I WAS STOPPED AT A RED LIGHT IN TRAFFIC (MY VEHICLE WAS IN IDLE STOP MODE), MY CAR SIMPLY DIED AND WOULD NOT RESTART WHEN THE TRAFFIC LIGHT TURNED GREEN AND I STEPPED ON THE GAS PEDAL TO MOVE FORWARD WITH TRAFFIC. IT TOOK NUMEROUS ATTEMPTS TO RE START THE VEHICLE WHILE STUCK IN VERY HEAVY TRAFFIC BEFORE IT GAINED POWER AND …
Read full complaint
WHEN I WAS STOPPED AT A RED LIGHT IN TRAFFIC (MY VEHICLE WAS IN IDLE STOP MODE), MY CAR SIMPLY DIED AND WOULD NOT RESTART WHEN THE TRAFFIC LIGHT TURNED GREEN AND I STEPPED ON THE GAS PEDAL TO MOVE FORWARD WITH TRAFFIC. IT TOOK NUMEROUS ATTEMPTS TO RE START THE VEHICLE WHILE STUCK IN VERY HEAVY TRAFFIC BEFORE IT GAINED POWER AND WAS ABLE TO DRIVE FORWARD. MY SAFETY WAS COMPROMISED I WAS IN THE MIDDLE OF MULTIPLE LANES OF MOVING TRAFFIC, IT WAS SCARY. NO WARNING LAMPS OR MESSAGES OCCURED PRIOR TO THE INCIDENT.
NHTSA ODI #11605085
Mileage unknown · Jul 26, 2024
EnginePower TrainUnknown Or Other
I was in traffic and we slowed down to a stop. Suddenly my car went to neutral and it didn’t want to go to Drive. I put emergency lights, as many cars were behind in the highway. I turned the car off and turned it back on. Then I was able to drive again! This has happened twice in the last 3 months.
NHTSA ODI #11604815
Mileage unknown · Jul 20, 2024
EngineUnknown Or Other
No warning lights or other indications occurred. This is the 2nd time while sitting at a stop light that the car has gone into neutral gear and it was unknown until the traffic signal turned green and I could not go. I could not shift into drive. The remedy required that I shut the car off and restarted (very little time between…
Read full complaint
No warning lights or other indications occurred. This is the 2nd time while sitting at a stop light that the car has gone into neutral gear and it was unknown until the traffic signal turned green and I could not go. I could not shift into drive. The remedy required that I shut the car off and restarted (very little time between) before putting it in gear. Both occurrences were with idle stop function on. There is an entire discussion forum on this exact issue on [XXX] . Being first in line at a stop with 4 other passengers and a line of drivers expecting me to go on green is a sure way to result in an accident. The car goes in for regular service next week and I will bring it to the dealer’s attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11603508
Mileage unknown · Jul 18, 2024
EngineUnknown Or Other
The car's Auto Start/Stop (AST) function is malfunctioning. It frequently fails to restart the engine after stopping, causing the engine to completely shut down at traffic signals. When this occurs, the car must be shifted to park and the engine manually restarted.
NHTSA ODI #11603274
Mileage unknown · Jul 9, 2024
Engine
Engine shuts off at red light as auto idle stop got activated. Then at green light when I press the accelerator my car was in”neutral”mode and it didn’t allow me to move. I had to put my car into parking then switch it off and restart it. People behind me were agitated and honking.
NHTSA ODI #11600341
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Apr 17, 2025
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence & remedy
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Additional source detail variants (2)
Interior Lighting
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Exterior Lighting
Honda (American Honda Motor Co.) is recalling certain 2014-2020 Acura MDX vehicles. Moisture may enter the tailgate lid light assembly and wiring harness, which can cause the interior and exterior lights to fail, including the lid lights, position lights, license plate lights and taillights.
Consequence: Vehicle lights that fail to illuminate can decrease visibility and increase the risk of a crash.
Remedy: Dealers will inspect the wiring and install a fuse harness, replace the lid light, and repair the body dust sealer, as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Acura's customer service at 1-800-382-2238. Acura's number for this recall is FLI. Vehicles included in this recall that were previously repaired under NHTSA recall number 19V-256 will need to have the new remedy completed.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Jun 29, 2023
Honda (American Honda Motor Co.) is recalling certain 2020-2021 Civic, 2020-2023 Ridgeline, 2021-2023 Passport, 2021-2022 Pilot, and 2020 Acura MDX vehicles. The tie rod fastener that connects the brake booster and the brake master cylinder may have been improperly assembled during manufacturing, which can cause the brake master cylinder to separate from the booster assembly.
Consequence & remedy
Consequence: Brake master cylinder separation can cause a loss of brake function and increase the risk of a crash.
Remedy: Dealers will inspect and repair the brake booster assembly as necessary, free of charge. Owner notification letters were mailed August 7, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are VEU, AEV, and ZET.
Mar 25, 2021
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Acura MDX, MDX Sport Hybrid, RDX, TLX, Honda Accord, Civic Hatchback, Insight, 2019 Acura ILX, Honda Accord Hybrid, Civic Coupe, Civic Coupe Si, Civic Sedan, Civic Sedan Si, Civic Type R, Fit, HR-V, Odyssey, Passport, Pilot and Ridgeline, and 2018-2019 CR-V vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the fuel pump assembly, free of charge. Owner letters were mailed May 18, 2021. Owners may contact Honda customer service at 1-888-234-2138. Note: This recall is an expansion of recall 20V-314.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
Illustration